Manuals / Hotpoint / Kitchen Appliance / Range

Hotpoint JB400DP1WW, JB400SPSS, JB400DP1BB manual Control Panel Removal

Models: JB400DP1BB JB400SPSS JB400DP1WW

1 57

Download 57 pages 40.66 Kb

Page 24

Control Panel Removal

Control Panel Removal

The control panel contains the ERC & the infinite heat switches. To Service:

1.Remove 3 ¼” hex heads at the top, in the back of the range.

2.Remove 2 Phillips screws under the control panel in the front of the range.

Copyright 2009

24

Image 24

Hotpoint JB400DP1WW, JB400SPSS, JB400DP1BB manual Control Panel Removal

Contents

GE JB400 Steam Clean Range Range ModelsIMPORTANT SAFETY NOTICE RECONNECT ALL GROUNDING DEVICESCopyright Plano Safety Glasses Steel Toe Shoes Dyneema Cut Resistant Glove Prescription Safety GlassesSafety Glasses must be compliant with ANSI Z87.1-2003Warranty CopyrightNomenclature J B 400 D P 1 WWJ = GE CopyrightModel / Serial Number Plate Anti-TipBracket CopyrightOven Door Removal •Fully open the doorCopyright •Close door to the door removal position •Firmly grasp both sides of the door at the topOven Door Removal CopyrightOven Door Re-Installation •Firmly grasp both sides of the door at the top•Close the oven door Oven Door Re-Installation•Fully open the door CopyrightDoor Gasket CopyrightDoor Gasket CopyrightDoor Switch Door Switch Replacement CopyrightCooktop •Open oven door•Lift cooktop •Use prop to support cooktop, if desiredCooktop Elements 8 Inch 2000W 6 Inch 1500W10Inch 3000W Inner – 1400W Outer – 1600W 6 Inch 1500WCooktop Element Replacement CopyrightCooktop Element Replacement •Mark and remove wires from terminals•Lift and remove burner from cooktop assembly •Disengage mounting clips from burner caseTemperature Limit / Hot Cooktop Light Switch CopyrightTemperature Limit / Hot Cooktop Light Switch 2.Detects when glass temperature above a unit has exceeded it’s limit of approximately 1031F and disconnects power to that unit. When the glass temperature cools below 1031F, the unit will turn back onCooktop Removal Cooktop Removal •Return cooktop to normally closed position•Lift rear of cooktop @ two inches CopyrightControl Panel Removal Control Panel Removal 3.Pull bottom of panel out while lifting panel up4.Lay panel on cooking surface CopyrightOven Sensor Oven Sensor Oven sensor disconnect plugCopyright T09 Control - ERC 2:31Display On / Off Feature 3:02Copyright Special Functions CopyrightT09 Control – ERC Removal •Remove ERC from frameCopyright 2 white – Sensor Orange / Yellow – Door Switch T09 Control - ERCOven Light Broil ElementKey Panel Test 3:02•Clock – Audible tone and display change Control Voltage - ERC CopyrightFault Codes FunctionKey s Conditions &Fault Codes CopyrightSteam Clean Operation 0:30Copyright Steam Clean Procedure To begin the steam cycle3.Close the door Steam Clean Procedure 4.Press the Steam Clean pad; then press Start/On0:30 CopyrightSteam Clean Procedure 10.Leave the door open to air drySteam Clean Procedure – IMPORTANT NOTES Hidden Bake Element •If element requires replacement, range left side panel needs to be removed Hidden Bake ElementHidden Bake Element CopyrightHidden Bake Element CopyrightHidden Bake Element CopyrightHidden Bake Element CopyrightHidden Bake Element CopyrightHidden Bake Element •Remove orange and yellow leads from bake element terminalsHidden Bake Element CopyrightHidden Bake Element Slide out element from compartment to removeCopyright Hidden Bake Element CopyrightOven Light CopyrightStrip Circuits CopyrightSchematic CopyrightWiring Diagram CopyrightEND OF PRESENTATION Copyright