Manuals / Hotpoint / Kitchen Appliance / Range

Hotpoint JB400DP1BB, JB400DP1WW, JB400SPSS manual Hidden Bake Element, Copyright

Models: JB400DP1BB JB400SPSS JB400DP1WW

1 57

Download 57 pages 40.66 Kb

Page 44

Manual background

Hidden Bake Element

After lifting or removing cooktop, remove two ¼” hex heads and a single Phillips screw from the top of the side panel.

Copyright 2009

44

Image 44

Hotpoint JB400DP1BB, JB400DP1WW, JB400SPSS manual Hidden Bake Element, Copyright

Contents

GE JB400 Steam Clean Range Range ModelsCopyright IMPORTANT SAFETY NOTICERECONNECT ALL GROUNDING DEVICES Plano Safety Glasses Steel Toe Shoes Dyneema Cut Resistant Glove Prescription Safety GlassesSafety Glasses must be compliant with ANSI Z87.1-2003Warranty CopyrightNomenclature J B 400 D P 1 WWJ = GE CopyrightModel / Serial Number Plate Anti-TipBracket CopyrightCopyright Oven Door Removal•Fully open the door •Close door to the door removal position •Firmly grasp both sides of the door at the topOven Door Removal CopyrightOven Door Re-Installation •Firmly grasp both sides of the door at the top•Close the oven door Oven Door Re-Installation•Fully open the door CopyrightDoor Gasket CopyrightDoor Gasket CopyrightDoor Switch Door Switch Replacement CopyrightCooktop •Open oven door•Lift cooktop •Use prop to support cooktop, if desiredCooktop Elements 8 Inch 2000W 6 Inch 1500W10Inch 3000W Inner – 1400W Outer – 1600W 6 Inch 1500WCooktop Element Replacement CopyrightCooktop Element Replacement •Mark and remove wires from terminals•Lift and remove burner from cooktop assembly •Disengage mounting clips from burner caseTemperature Limit / Hot Cooktop Light Switch CopyrightTemperature Limit / Hot Cooktop Light Switch 2.Detects when glass temperature above a unit has exceeded it’s limit of approximately 1031F and disconnects power to that unit. When the glass temperature cools below 1031F, the unit will turn back onCooktop Removal Cooktop Removal •Return cooktop to normally closed position•Lift rear of cooktop @ two inches CopyrightControl Panel Removal Control Panel Removal 3.Pull bottom of panel out while lifting panel up4.Lay panel on cooking surface CopyrightOven Sensor Copyright Oven SensorOven sensor disconnect plug T09 Control - ERC 2:31Copyright Display On / Off Feature3:02 Special Functions CopyrightCopyright T09 Control – ERC Removal•Remove ERC from frame 2 white – Sensor Orange / Yellow – Door Switch T09 Control - ERCOven Light Broil Element•Clock – Audible tone and display change Key Panel Test3:02 Control Voltage - ERC CopyrightFault Codes FunctionKey s Conditions &Fault Codes CopyrightCopyright Steam Clean Operation0:30 3.Close the door Steam Clean ProcedureTo begin the steam cycle Steam Clean Procedure 4.Press the Steam Clean pad; then press Start/On0:30 CopyrightSteam Clean Procedure 10.Leave the door open to air drySteam Clean Procedure – IMPORTANT NOTES Hidden Bake Element •If element requires replacement, range left side panel needs to be removed Hidden Bake ElementHidden Bake Element CopyrightHidden Bake Element CopyrightHidden Bake Element CopyrightHidden Bake Element CopyrightHidden Bake Element CopyrightHidden Bake Element •Remove orange and yellow leads from bake element terminalsHidden Bake Element CopyrightCopyright Hidden Bake ElementSlide out element from compartment to remove Hidden Bake Element CopyrightOven Light CopyrightStrip Circuits CopyrightSchematic CopyrightWiring Diagram CopyrightEND OF PRESENTATION Copyright