Invacare R100, R102, R110, R117, R121 Installing the Reliant Scale

ACCESSORIES

Part No. 1145810 43 Electric Portable Patient Lift

Installing the Reliant Scale

 WARNING

Patient and sling MUST be removed from the lift during ALL installation proce-

dures.

NOTE:Forthisprocedure,refertoFIGURE 8.2.

1. PositiontheloadcellassemblyoftheReliantScaleintotheboommountingbracket.

RefertoDetailʺAʺ.

NOTE:Use1/4‐inchnylonwasher.

2. SecuretheReliantScaletotheboommountingbracketwithashoulderbolt,twonylon

washersandalocknut.Securelytighten.RefertoDetailʺAʺforwas herorientation.

NOTE:Ensuretheshaftoftheshoulderboltpassesthroughbothsidesoftheboommounting

bracket.

3. Insertswivelbarpinwithtwonylonwashersthroughtheswivelbar.RefertoDetail

ʺBʺ.

4. Alignthemountingholesintheswivelbarpinwiththemountingholesintheload

cellassembly.RefertoDetailʺBʺ.

5. Secureswivelbarpintotheloadcellassemblywiththeprovidedmountingscrewand

locknut.Securelytighten.RefertoDetailʺBʺ.

 WARNING

After ANY adjustments, repair or service and BEFORE use, make sure all attaching

hardware is tightened securely - otherwise injury or damage may occur.

6. Weighthepatient.RefertoOperatingtheScaleonpage44andWeighingthePat ient

onpage 45.

FIGURE 8.2 Installing the Reliant Scale

Locknut

Swivel Bar

Nylon

Washers

Swivel Bar

Pin

Mounting

Screw

Boom

Reliant

Scale

Boom

Mounting

Bracket

Reliant

Scale

Nylon

Washer

Load Cell

Assembly

Shoulder

Bolt

DETAIL “B”

DETAIL “A”

Locknut

Nylon

Washer

Contents

Main WARNING Page TABLE OF CONTENTS Page REGISTER YOUR PRODUCT PRODUCT REGISTRATION FORM Page SPECIAL NOTES NOTICE LABEL LOCATION LABEL LOCATION WARNING WARNING SPECIFICATIONS SPECIFICATIONS Patient Lift *NOTE:Vari esdependinguponloadandstroke. SPECIFICATIONS Full Body, Divided Leg and Toileting Slings *NOTE:Slingsmadeofameshmaterial. NOTE:Alldimensionsareininchesexceptwherenoted. Reliant Scale RLS6 SECTION 1GENERAL GUIDELINES Assembling the Patient Lift Operating the Patient Lift Using the Sling Lifting the Patient Transferring the Patient Performing Maintenance Electrical - Grounding Instructions Pinch Points SECTION 2 INSTALLATION Unpacking the Patient Lift Assembling the Mast to the Base Assembling the Boom Actuator Installing the Leg Actuator to the Base INSTALLATION FIGURE 2.4 Patient Lift Components Mounting the Battery Charger SECTION 3OPERATING THE PATIENT LIFT Using the Pendant Buttons Raising/Lowering the Boom Opening/Closing the Legs Activating a Mechanical Emergency Release Primary Emergency Release Secondary Emergency Release Performing an Emergency Stop Charging the Battery Page SECTION 4LIFTING THE PATIENT Positioning the Patient Lift Attaching a Sling Lifting/Moving the Patient Page Page SECTION 5TRANSFERRING THE PATIENT Transferring to a Commode Chair Transferring to a Standard Commode Transferring to a Bathing Unit Transferring to a Wheelchair Page TROUBLESHOOTING SECTION 6 TROUBLESHOOTING NOTE:Ifproblemsarenotremediedbythesuggestedmeans,pleasecontactyourdealeror Invacare. SYMPTOMS FAULTS SOLUTION MAINTENANCE SECTION 7 MAINTENANCE Maintenance Safety Inspection Checklist INSTITUTIONAL INSPECT/ADJUST MONTHLY IN-HOME INSPECT EVERY SIX MONTHS Lubricating the Lift Detecting Wear and Damage Cleaning the Sling and the Lift Replacing the Boom Actuator Checking and Tightening Mast Pivot Bolt Replacing the Swivel Bar Maintaining the Base Adjustment Replacing Casters/Forks Replacing Rear Casters Replacing Front Casters Replacing Forks SECTION 8 ACCESSORIES Reliant Scale RLS6 Removing the Swivel Bar Installing the Reliant Scale ACCESSORIES Operating the Scale KEY Keypad Functions NOTE:Forthisprocedure,refertoFIGURE 8.3. FIGURE 8.3 Operating the Scale - Keypad Functions Weighing the Patient Replacing the Battery Calibrating the Reliant Scale Troubleshooting Display Codes Page Page LIMITED WARRANTY LIMITED WARRANTY