Troubleshooting Guide
Leakage Checkpoints
Usc this guide to check a q,eaking" watcr hcatcr. Many st_spcct-
cd "l,cakers" are not leaking tanks. Olden the source of the water can bc found and corrcctcd.
lfyou are not thoroughly J:amiliar _4th clcctric codcs, thc watcr
heater, and safety practices, contact your local Sears Service Center to check the water heater.
®*Condcnsation may bc sccn on pipcs in humid wcathcr or plpc connections may bc Icaking.
®Thc primary anodc rod may bc lcaklng.
© Small amounts of water fi'om
@*Thc
®Thc clcmcnts may bc leaking at the tank fittlng,
AWARNING
HAZARD OF ELECTRICAL $HOCKI Before removing any accesspanelsor servidng the water
heater, make sure the electrical supply to the water heater _sturned "OFF". Failure to do this
could result _n DEATH_ SERIOUS BODILY INJUR_ OR PROPERTY DAMAGE.
Turn dcctrical powcr "OFF", rcmovc acccss pancls and insolation block and pad. If lcaking around clcmcnts,
I_bllow propcr draining instructions and rcmovc element. Rcposltlon or replace gaskct on element. Place element into opcnlng andtightcn scct_rcly.Then follow
"Filling thc Watcr Hcatcr" instructions in thc "Insvallatlon Instructions" section,
@Water from drain waivemay bc duc to thc vdvc being opcncd slightly.
@*Thc drain valvc may bc lcaklng at thc tank fi'Ltting.
@*Water in the water heater bottom or on thc floor may
bc from condcnsation, loosc conncctions or the
water sourccs is made and ncccssary corrcctlvc steps takcn,
bcakagc from othcr applianccs, watcrlincs, or ground seepage should also bc chcckcd,
NOTE: *To check where threaded portion enters tank, insert cotton swab betwcenjacket opening and firtlng÷ If cotton is wet_ follow "Draining' ins¢_c- tions in the "Service and Adjostmen£ _ section and then remove fitting. Pat pipe dope or _¢flon _ape on
the _hreads and replace. Then follow "Filling the
Water Heater" instractions in the "Installation
Ins*Ja_ctlon¢' section.
(cont'd)
CAUTIONI
I
Read this manual tint, then before checking•the water I heater make sure the electric supply has been turned
"OFF", and never turn the electric supply "ON" before
the tank s completely full of waten
®
24