Land Pride
Table of Contents
Table of Contents
Important Safety Information . . . . . . . . . . .1
Safety Notations . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Safety Rules . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
General . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Transporting . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Tire Handling & Repair . . . . . . . . . . . . . . . . . . . 2
Safety Labels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Introduction . . . . . . . . . . . . . . . . . . . . . . . .7
Using This Manual . . . . . . . . . . . . . . . . . . . . . . . . . 7
Terminology: . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Definitions: . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Owner Assistance . . . . . . . . . . . . . . . . . . . . . . . . . 7
Serial Number Plate . . . . . . . . . . . . . . . . . . . . . 7
Section 1 Assembly and Setup . . . . . . . . .8
Tractor Requirements . . . . . . . . . . . . . . . . . . . . . . 8
Before You Start . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Dealer Cutter Assembly & Preparations . . . . . . . . 8
Left & Right Wing Axle Assembly . . . . . . . . . . . . . . 8
Hitch Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Slow Moving Vehicle
Bundle Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Hydraulic Plumbing . . . . . . . . . . . . . . . . . . . . . . . . 9
Tractor Hookup . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Section 2 Operating Instructions . . . . . .12
Operating Check List . . . . . . . . . . . . . . . . . . . . . . 12
Transporting . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Parking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Section 4 Troubleshooting . . . . . . . . . . .16
Section 5 Maintenance and Lubrication .17
Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17 Service Cutting Blades . . . . . . . . . . . . . . . . . . . . . 17 Skid Shoes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17 Clutch
Axle Hub Bearing . . . . . . . . . . . . . . . . . . . . . . 19 Wing Hinges (6) . . . . . . . . . . . . . . . . . . . . . . . . 19 Ratchet Jack . . . . . . . . . . . . . . . . . . . . . . . . . . 19 Axle Rockshaft & Axle Link . . . . . . . . . . . . . . . 20 Main Hitch . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20 Gearbox . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20 Divider Box . . . . . . . . . . . . . . . . . . . . . . . . . . . 20 Driveline Shaft . . . . . . . . . . . . . . . . . . . . . . . . . 21 Drive line Shafts . . . . . . . . . . . . . . . . . . . . . . . 21 PTO Constant Velocity Shaft . . . . . . . . . . . . . . 21
Section 6 Specifications and Capacities 23
Section 7 Appendix . . . . . . . . . . . . . . . . .24
Tire Inflation Chart . . . . . . . . . . . . . . . . . . . . . . . . 24 Torque Values Chart for Common Bolt Sizes . . . . 24 Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Section 3 Adjustments . . . . . . . . . . . . . . .14
Center Deck Level Adjustments . . . . . . . . . . . . . . 14
Center Deck Rear Axle Arms Adjustment . . . . . . 14
Wing Deck Level Adjustments . . . . . . . . . . . . . . . 15
Wing Deck Tailwheel Rubber Bumper Adjustment 15
© Copyright 2008 All rights Reserved
Land Pride provides this publication “as is” without warranty of any kind, either expressed or implied. While every precaution has been taken in the preparation of this manual, Land Pride assumes no responsibility for errors or omissions. Neither is any liability assumed for damages resulting from the use of the information contained herein. Land Pride reserves the right to revise and improve its products as it sees fit. This publication describes the state of this product at the time of its publication, and may not reflect the product in the future.
Land Pride is a registered trademark.
All other brands and product names are trademarks or registered trademarks of their respective holders.
Printed in the United States of America.
RC45180 & RCM45180 Rotary Cutter | 7/14/08 |
