Lennox Hearth PI40

NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.

Front Door Opening and Removal

CAUTION: Do not open the front door when the insert is hot.

To remove the door, swing the left and right side doors A open. Pull

the front door handle B to the front and swing the front door open. Lift

the front door up and off the hinges as shown in Figure 41 (see C). To

reinstall the door repeat the steps in reverse order.

Side Door Removal

To remove the door,

1. Swing the door open

2. Lift the door up, and

3. Pull the bottom of the door out and down - pulling the top hinge pin

out of the retaining hole in the top hinge bracket.

To reinstall the door, slide the pin on the top of the door up and into the

hole in the upper hinge bracket. Slide the pin on the bottom of the door

into the hole in the pedestal base and rotate the door closed.

Figure 41

Figure 42

Front Door

Side

Door

Hopper Extension

Hopper Lid

Figure 40

Contents

Main INSTALLATION AND OPERATION MANUAL Save These Instructions For Future Reference Pellet Insert Model Winslow (PI40) Pellet-Fired Fireplace Insert WARNINGS IMPORTANT SAFETY AND WARNIING INFORMATION READ THIS MANUAL IN ITS ENTIRETY AND UNDER- STAND THESE RULES TO FOLLOW FOR SAFETY. WARNING WARNING CONGRATULATIONS! TABLE OF CONTENTS PRODUCT IS SUBJECT TO CHANGE WITHOUT NOTICE USING THIS MANUAL PLANNING YOUR INSTALLATION WARNING Electrical Electrical Generator Operation Questions To Ask Local Building Ofcial WARNING SELECTING A LOCATION CAUTION Ventilation Requirements - FEATURES AND SPECIFICATIONS CAUTION THE USE OF UNAPPROVED, DIRTY, WET AND/OR HIGH SALT CONTENT FUEL WILL VOID THE WAR- RANTY! Front View Side View Figure 1 Figure 2 MINIMUM FIREPLACE SIZE Figure 5 Figure 3 IMPORTANT Control Board Installation Venting Vent Termination Requirements: INSTALLATION Page Insert Leveling Surround (Flange) Installation Figure 11A Figure 10 Figure 12 Figure 11B Figure 11C Mobile Home Installations Fireplace Installation Using Standard Surround Kits (P/N 79004, 79005, 79006 and 79007) Wiring Block B Rear View of Control Board A Page Door Grill Installation Instructions Figure 23 Figure 22 Figure 24 IMPORTANT Figure 21 Brick Panel Installation Figure 26 A B Figure 27 Figure 25 Figure 28 Page Page Control Board Figure 34 Filling the Hopper Lighting WARNINGS 234 1 Off High Heat Selector Knob Page Figure 35 Figure 36A Cleaning the Combustion Blower Figure 36B Cleaning the Vent Pipe Figure 36C Blower Duct Page Page A Draft Adjuster Page Page Surround Panel Kits Door Trim Surround Trim Common Accessories ACCESSORIES Grill Finish Page Page Page E C Figure 63 Figure 64 Page WARRANTY PRODUCT REFERENCE INFORMATION REPLACEMENT PARTS