Hardware Maintenance Manual
Lenovo G560
First Edition Jan Copyright Lenovo 2010. All rights reserved
Restoring the factory contents by using
Contents
Handling devices that are sensitive to
About this manual
Lenovo G560
Safety information
Safety information
Lenovo G560 Hardware Maintenance Manual
General safety
Electrical safety
Safety information
Lenovo G560 Hardware Maintenance Manual
Power supply units Pumps Blowers and fans Motor generators
Safety inspection guide
Safety information
Grounding requirements
Handling devices that are sensitive to electrostatic discharge
Lenovo G560 Hardware Maintenance Manual
Safety notice
Safety notices multilingual translations
Safety information
Safety notice DANGER
Lenovo G560 Hardware Maintenance Manual
Safety notice DANGER
Safety information
The battery pack contains small amounts of nickel. Do not disassemble it, throw it into fire or water, or short-circuit it. Dispose of the battery pack as required by local ordinances or regulations. Use only the battery in the appropriate parts listing when replacing the battery pack. Use of an incorrect battery can result in ignition or explosion of the battery
Safety notice DANGER
Lenovo G560 Hardware Maintenance Manual
The lithium battery can cause a fire, an explosion, or a severe burn. Do not recharge it, remove its polarized connector, disassemble it, heat it above 100C 212F, incinerate it, or expose its cell contents to water. Dispose of the battery as required by local ordinances or regulations. Use only the battery in the appropriate parts listing. Use of an incorrect battery can result in ignition or explosion of the battery
Safety notice
Safety information
If the LCD breaks and the fluid from inside the LCD gets into your eyes or on your hands, immediately wash the affected areas with water at least for 15 minutes. Seek medical care if any symptoms caused by the fluid are present after washing
Safety notice DANGER
Lenovo G560 Hardware Maintenance Manual
Safety notice DANGER
To avoid shock, do not remove the plastic cover that protects the lower part of the inverter card
Safety notice DANGER
Safety information
Before removing any FRU, turn off the computer, unplug all power cords from electrical outlets, remove the battery pack, and then disconnect any interconnecting cables
Laser compliance statement
Lenovo G560 Hardware Maintenance Manual
DANGER
Safety information
Strategy for replacing FRUs
Important service information
Before replacing parts
Lenovo G560 Hardware Maintenance Manual
Strategy for replacing a hard disk drive
Important service information
Important notice for replacing a system board
Lenovo G560 Hardware Maintenance Manual
Important information about replacing RoHS compliant FRUs
Replacement FRU
General checkout
General checkout
Important notes
What to do first
The following are not covered under warranty
Lenovo G560 Hardware Maintenance Manual
Checking operational charging
Power system checkout
Checking the AC adapter
General checkout
Checking the battery pack
Lenovo G560 Hardware Maintenance Manual
Restore of factory default
Related service information
Restoring the factory contents by using OneKey Recovery
Using recovery discs
Supervisor password
Passwords
Power-on password
Lenovo G560 Hardware Maintenance Manual
Sleep standby mode
Power management
Screen blank mode
Related service information
Hibernation mode
Lenovo G560 Hardware Maintenance Manual
Lenovo G560
Specifications
Lenovo G560
Lenovo G560 Hardware Maintenance Manual
Table 1. Specifications continued
The system status indicators below show the computer status
Status indicators
Lenovo G560
Table 2. Status indicators continued
Lenovo G560 Hardware Maintenance Manual
80% of its capacity, or the computer is operating on
Lenovo G560
Fn key combinations
Table 4. Fn key combinations
Plastic to plastic
FRU replacement notices
Screw notices
Logic card to plastic
Lenovo G560
Removing and replacing an FRU
DANGER
Figure 1. Removal steps of battery pack
1010 Battery pack
Lenovo G560 Hardware Maintenance Manual
DANGER
Lenovo G560
1020 Dummy cards
For access, remove this FRU “1010 Battery pack” on page
Remove two dummy cards in the direction shown by arrows 1
Screw quantity
Lenovo G560 Hardware Maintenance Manual
Step
Color
1040 Hard disk drive
Lenovo G560
When installing Make sure that the HDD connector is attached firmly
Lenovo G560 Hardware Maintenance Manual
6 kgfcm
Lenovo G560
1050 Optical drive
Figure 5. Removal steps of optical drive
Lenovo G560 Hardware Maintenance Manual
1060 DIMM
Figure 6. Removal steps of DIMM
Figure 7. Removal steps of fan assembly and heat sink assembly
1070 Fan assembly and Heat Sink assembly
Lenovo G560
Lenovo G560 Hardware Maintenance Manual
Lift the fan assembly and heat sink assembly in the direction shown by arrow 4. Be careful not to damage the connector
When installing
Lenovo G560
Lenovo G560 Hardware Maintenance Manual
1080 CPU
Figure 8. Removal steps of CPU
Figure 9. Removal steps of PCI Express Mini Card for wireless LAN/WAN
1090 PCI Express Mini Card for wireless LAN/WAN
Lenovo G560
Notes wireless LAN card has 2 cables in step
Lenovo G560 Hardware Maintenance Manual
When installing
Lenovo G560
1100 Keyboard
Figure 10. Removal steps of keyboard
Lenovo G560 Hardware Maintenance Manual
Figure 10. Removal steps of keyboard continued
Lenovo G560
1110 Keyboard bezel
Figure 11. Removal steps of keyboard bezel
Lenovo G560 Hardware Maintenance Manual
Figure 11. Removal steps of keyboard bezel continued
Lift the keyboard bezel a little, detach the speaker connector in the direction shown by arrows 7, and then remove the keyboard bezel
Lenovo G560
1120 Speakers, power board and touch inductive panel
Lenovo G560 Hardware Maintenance Manual
Lenovo G560
Remove two screws 2 and remove the power board
Notes The touch inductive panel is fixed on the keyboard bezel
Important notices for handling the system board
1130 System board and ExpressCard slot assembly
Lenovo G560 Hardware Maintenance Manual
When installing Make sure that the connector is attached firmly
Lenovo G560
Lenovo G560 Hardware Maintenance Manual
Remove the system board in the direction shown by arrow
Lenovo G560
Remove the ExpressCard slot assembly in the direction shown by arrow
Turn the system board over and remove two screws
Lenovo G560 Hardware Maintenance Manual
1140 LCD unit
Figure 14. Removal steps of LCD unit
When installing
Lenovo G560
Remove four screws
Lenovo G560 Hardware Maintenance Manual
Figure 14. Removal steps of LCD unit continued
Remove the LCD unit in the direction shown by arrows
Figure 15. Removal steps of bluetooth daughter card and base cover
1150 Bluetooth daughter card and base cover
Lenovo G560
Lenovo G560 Hardware Maintenance Manual
When installing Make sure that the power connector is attached firmly
For models in Japan
Note Applying labels to the base cover
For models in China
Lenovo G560
For models in other countries or regions
Lenovo G560 Hardware Maintenance Manual
Lenovo G560
1160 LCD front bezel
Figure 16. Removal steps of LCD front bezel
Lenovo G560 Hardware Maintenance Manual
1170 LCD panel and hinges
Figure 17. Removal steps of LCD panel and hinges
Figure 17. Removal steps of LCD panel and hinges continued
Lenovo G560
2.5 kgfcm
Lenovo G560 Hardware Maintenance Manual
1180 Integrated camera
Figure 18. Removal steps of integrated camera
Figure 19. Removal steps of antenna assembly and LCD cover
1190 Antenna assembly and LCD cover
Lenovo G560
Front view
Locations
Lenovo G560 Hardware Maintenance Manual
Bottom and Left-side view
Right-side view
Lenovo G560
This section presents the following service parts “Overall” on page
Parts list
Lenovo G560 Hardware Maintenance Manual
“AC adapters” on page “Power cords” on page
Overall
Lenovo G560
No. FRU
Lenovo G560 Hardware Maintenance Manual
Table 5. Parts list-Overall
FRU no
Table 5. Parts list-Overall continued
Lenovo G560
Lenovo G560 Hardware Maintenance Manual
Table 5. Parts list-Overall continued
Lenovo G560
LCD FRUs
In Lenovo G560, there are following types of LCDs “15.6-in. HD TFT”
Table 6. Parts list-15.6-in. HD TFT
Lenovo G560 Hardware Maintenance Manual
15.6-in. HD TFT
Table 7. Parts list-Keyboard
Keyboard
Lenovo G560
Lenovo G560 Hardware Maintenance Manual
Table 7. Parts list-Keyboard continued
Miscellaneous parts
Lenovo G560
Lenovo G560 Hardware Maintenance Manual
AC adapters
Table 9. Parts list-3-pin AC adapters
Table 10. Parts list-3-pin power cords
Power cords
Lenovo G560
Lenovo G560 Hardware Maintenance Manual
Table 10. Parts list-3-pin power cordscontinued
Notices
Notices
Trademarks
Lenovo G560 Hardware Maintenance Manual