Hardware Maintenance Manual
Lenovo G560
First Edition Jan Copyright Lenovo 2010. All rights reserved
Contents
Restoring the factory contents by using
Handling devices that are sensitive to
About this manual
Lenovo G560
Safety information
Safety information
Lenovo G560 Hardware Maintenance Manual
General safety
Electrical safety
Safety information
Lenovo G560 Hardware Maintenance Manual
Power supply units Pumps Blowers and fans Motor generators
Safety inspection guide
Safety information
Handling devices that are sensitive to electrostatic discharge
Grounding requirements
Lenovo G560 Hardware Maintenance Manual
Safety notices multilingual translations
Safety notice
Safety information
Safety notice DANGER
Lenovo G560 Hardware Maintenance Manual
Safety information
Safety notice DANGER
The battery pack contains small amounts of nickel. Do not disassemble it, throw it into fire or water, or short-circuit it. Dispose of the battery pack as required by local ordinances or regulations. Use only the battery in the appropriate parts listing when replacing the battery pack. Use of an incorrect battery can result in ignition or explosion of the battery
Lenovo G560 Hardware Maintenance Manual
Safety notice DANGER
The lithium battery can cause a fire, an explosion, or a severe burn. Do not recharge it, remove its polarized connector, disassemble it, heat it above 100C 212F, incinerate it, or expose its cell contents to water. Dispose of the battery as required by local ordinances or regulations. Use only the battery in the appropriate parts listing. Use of an incorrect battery can result in ignition or explosion of the battery
Safety information
Safety notice
If the LCD breaks and the fluid from inside the LCD gets into your eyes or on your hands, immediately wash the affected areas with water at least for 15 minutes. Seek medical care if any symptoms caused by the fluid are present after washing
Lenovo G560 Hardware Maintenance Manual
Safety notice DANGER
Safety notice DANGER
To avoid shock, do not remove the plastic cover that protects the lower part of the inverter card
Safety information
Safety notice DANGER
Before removing any FRU, turn off the computer, unplug all power cords from electrical outlets, remove the battery pack, and then disconnect any interconnecting cables
Laser compliance statement
Lenovo G560 Hardware Maintenance Manual
DANGER
Safety information
Important service information
Before replacing parts
Strategy for replacing FRUs
Lenovo G560 Hardware Maintenance Manual
Important service information
Strategy for replacing a hard disk drive
Important notice for replacing a system board
Important information about replacing RoHS compliant FRUs
Lenovo G560 Hardware Maintenance Manual
Replacement FRU
General checkout
General checkout
Important notes
The following are not covered under warranty
What to do first
Lenovo G560 Hardware Maintenance Manual
Power system checkout
Checking the AC adapter
Checking operational charging
General checkout
Checking the battery pack
Lenovo G560 Hardware Maintenance Manual
Related service information
Restoring the factory contents by using OneKey Recovery
Restore of factory default
Using recovery discs
Passwords
Power-on password
Supervisor password
Lenovo G560 Hardware Maintenance Manual
Power management
Screen blank mode
Sleep standby mode
Related service information
Hibernation mode
Lenovo G560 Hardware Maintenance Manual
Specifications
Lenovo G560
Lenovo G560
Lenovo G560 Hardware Maintenance Manual
Table 1. Specifications continued
Status indicators
The system status indicators below show the computer status
Lenovo G560
Lenovo G560 Hardware Maintenance Manual
Table 2. Status indicators continued
80% of its capacity, or the computer is operating on
Fn key combinations
Lenovo G560
Table 4. Fn key combinations
FRU replacement notices
Screw notices
Plastic to plastic
Logic card to plastic
Removing and replacing an FRU
Lenovo G560
DANGER
1010 Battery pack
Lenovo G560 Hardware Maintenance Manual
Figure 1. Removal steps of battery pack
DANGER
1020 Dummy cards
For access, remove this FRU “1010 Battery pack” on page
Lenovo G560
Remove two dummy cards in the direction shown by arrows 1
Lenovo G560 Hardware Maintenance Manual
Step
Screw quantity
Color
1040 Hard disk drive
Lenovo G560
Lenovo G560 Hardware Maintenance Manual
When installing Make sure that the HDD connector is attached firmly
6 kgfcm
1050 Optical drive
Lenovo G560
Figure 5. Removal steps of optical drive
1060 DIMM
Lenovo G560 Hardware Maintenance Manual
Figure 6. Removal steps of DIMM
1070 Fan assembly and Heat Sink assembly
Figure 7. Removal steps of fan assembly and heat sink assembly
Lenovo G560
Lenovo G560 Hardware Maintenance Manual
Lift the fan assembly and heat sink assembly in the direction shown by arrow 4. Be careful not to damage the connector
When installing
Lenovo G560
1080 CPU
Lenovo G560 Hardware Maintenance Manual
Figure 8. Removal steps of CPU
1090 PCI Express Mini Card for wireless LAN/WAN
Figure 9. Removal steps of PCI Express Mini Card for wireless LAN/WAN
Lenovo G560
Lenovo G560 Hardware Maintenance Manual
Notes wireless LAN card has 2 cables in step
When installing
1100 Keyboard
Lenovo G560
Figure 10. Removal steps of keyboard
Lenovo G560 Hardware Maintenance Manual
Figure 10. Removal steps of keyboard continued
1110 Keyboard bezel
Lenovo G560
Figure 11. Removal steps of keyboard bezel
Lenovo G560 Hardware Maintenance Manual
Figure 11. Removal steps of keyboard bezel continued
Lift the keyboard bezel a little, detach the speaker connector in the direction shown by arrows 7, and then remove the keyboard bezel
Lenovo G560
1120 Speakers, power board and touch inductive panel
Lenovo G560 Hardware Maintenance Manual
Remove two screws 2 and remove the power board
Lenovo G560
Notes The touch inductive panel is fixed on the keyboard bezel
1130 System board and ExpressCard slot assembly
Important notices for handling the system board
Lenovo G560 Hardware Maintenance Manual
When installing Make sure that the connector is attached firmly
Lenovo G560
Lenovo G560 Hardware Maintenance Manual
Remove the system board in the direction shown by arrow
Remove the ExpressCard slot assembly in the direction shown by arrow
Lenovo G560
Turn the system board over and remove two screws
1140 LCD unit
Lenovo G560 Hardware Maintenance Manual
Figure 14. Removal steps of LCD unit
When installing
Lenovo G560
Lenovo G560 Hardware Maintenance Manual
Figure 14. Removal steps of LCD unit continued
Remove four screws
Remove the LCD unit in the direction shown by arrows
1150 Bluetooth daughter card and base cover
Figure 15. Removal steps of bluetooth daughter card and base cover
Lenovo G560
Lenovo G560 Hardware Maintenance Manual
When installing Make sure that the power connector is attached firmly
Note Applying labels to the base cover
For models in China
For models in Japan
Lenovo G560
For models in other countries or regions
Lenovo G560 Hardware Maintenance Manual
1160 LCD front bezel
Lenovo G560
Figure 16. Removal steps of LCD front bezel
1170 LCD panel and hinges
Lenovo G560 Hardware Maintenance Manual
Figure 17. Removal steps of LCD panel and hinges
Lenovo G560
Figure 17. Removal steps of LCD panel and hinges continued
2.5 kgfcm
1180 Integrated camera
Lenovo G560 Hardware Maintenance Manual
Figure 18. Removal steps of integrated camera
1190 Antenna assembly and LCD cover
Figure 19. Removal steps of antenna assembly and LCD cover
Lenovo G560
Locations
Front view
Lenovo G560 Hardware Maintenance Manual
Right-side view
Bottom and Left-side view
Lenovo G560
Parts list
Lenovo G560 Hardware Maintenance Manual
This section presents the following service parts “Overall” on page
“AC adapters” on page “Power cords” on page
Overall
Lenovo G560
Lenovo G560 Hardware Maintenance Manual
Table 5. Parts list-Overall
No. FRU
FRU no
Table 5. Parts list-Overall continued
Lenovo G560
Lenovo G560 Hardware Maintenance Manual
Table 5. Parts list-Overall continued
LCD FRUs
Lenovo G560
In Lenovo G560, there are following types of LCDs “15.6-in. HD TFT”
Lenovo G560 Hardware Maintenance Manual
Table 6. Parts list-15.6-in. HD TFT
15.6-in. HD TFT
Keyboard
Table 7. Parts list-Keyboard
Lenovo G560
Lenovo G560 Hardware Maintenance Manual
Table 7. Parts list-Keyboard continued
Miscellaneous parts
Lenovo G560
AC adapters
Lenovo G560 Hardware Maintenance Manual
Table 9. Parts list-3-pin AC adapters
Power cords
Table 10. Parts list-3-pin power cords
Lenovo G560
Lenovo G560 Hardware Maintenance Manual
Table 10. Parts list-3-pin power cordscontinued
Notices
Notices
Trademarks
Lenovo G560 Hardware Maintenance Manual