Lenovo T60, T60P Removing and replacing a FRU , 60

When installing: Make sure that the hard disk drive connector is attached firmly.

When installing: The rubber rails on the hard disk drive must be attached to the

replacement drive. Otherwise the drive cannot be installed

properly.

Removing and replacing a FRU

60 MT 6369, 6370, 6371, 6372, 8741, 8742, 8743, and 8744

Contents

Main ThinkP ad T60 and T60p (1 5.4-in ch widescreen) Hardware Maintenance Manual Page Page Page Contents About this manual . . . . . . . . . .1 Introduction . . . . . . . . . . . . .3 Copyright Lenovo 2006, 2007 General descriptions . . . . . . . . .19 ThinkPad T60 and T60p (15.4-inch widescreen) . . . . . . . . . . . .33 iv About this manual Copyright Lenovo 2006, 2007 2 Introduction Important service information Copyright Lenovo 2006, 2007 Strategy for replacing FRUs Strategy for replacing a hard disk drive 4 Important notice for replacing a system board How to use error messages Strategy for replacing FRUs for CTO, CMV, and GA V Product definition FRU identification for CTO, CMV, and GA V products Introduction 5 Using PEW Using eSupport Using the HMM Important information about replacing RoHS compliant FRUs Current or original part Replacement FRU Current or original part Important service information Diskette compatibility matrix Introduction 7 drive Diskette capacity Safety notices: multilingual translations Safety notices 8 Safety notice 3 Introduction 9 Safety notice 4 Safety notices 10 Safety notice 5 Safety notice 6 Introduction Safety notice 7 Safety notice 8 Safety notices 12 Safety information Introduction 13 Observe the following rules when working on electrical equipment. General safety Electrical safety Safety information 14 Safety inspection guide Introduction 15 Handling devices that are sensitive to electrostatic discharge 16 Grounding requirements Safety information Laser compliance statement Introduction 17 CAUTION: Laser compliance statement Laser compliance statement 18 General descriptions Copyright Lenovo 2006, 2007 Read this first Before you go to the checkout guide, be sure to read this section. What to do first Read this first 20 Related service information General descriptions 21 Service Web site Restoring the factory contents by using Product Recovery discs Passwords 22 Related service information General descriptions 23 How to remove the power-on password How to remove the hard-disk password Power management 24 Screen blank mode Standby mode Related service information Hibernation mode Related service information 26 Checkout guide General descriptions 27 Testing the computer Creating the PC-Doctor diagnostics diskette WirelessLAN Checkout guide 28 The options on the test menu are as follows: General descriptions 29 Detecting system information with PC-Doctor PC-Doctor can detect the following system information: Hardware Info Utility 30 Power system checkout Checking the ac adapter Checkout guide 1 2 Checking operational charging Checking the battery pack 1(+)2(+)3456(-) 7(-) Terminal Voltage (V dc) 1 + 0 to + 12.6 7 Ground () Checking the backup battery Black (-) 32 Wire Voltage (V dc) Red +2.5 to +3.2 Black Ground Checkout guide ThinkPad T60 and T60p (15.4-inch widescreen) Copyright Lenovo 2006, 2007 Product overview 34 (continued) Processor v Intel Specifications ThinkPad T60 and T60p (15.4-inch widescreen) 35 36 Status indicators The system status indicators show the status of the computer, as follows: ThinkPad T60 and T60p (15.4-inch widescreen) 37 1 2 3 4 5 6 7 8 9 10 8910 Product overview 38 Indicator Meaning 9 AC power Green: The computer is connected to the ac power supply. 10 Standby status ThinkPad T60 and T60p (15.4-inch widescreen) 39 FRU tests The following table shows the test for each FRU. 40 (continued) Product overview ThinkPad T60 and T60p (15.4-inch widescreen) 41 Fn key combinations 42 (continued) Product overview ThinkPad T60 and T60p (15.4-inch widescreen) 43 44 Symptom-to-FRU index ThinkPad T60 and T60p (15.4-inch widescreen) 45 System board. Numeric error codes 0175 Bad CRC1, stop POST taskThe EEPROM checksum is not correct. Symptom-to-FRU index 46 Page Symptom-to-FRU index 48 Error messages ThinkPad T60 and T60p (15.4-inch widescreen) 49 Device Error. 1. The device you want to boot from. Beep symptoms No-beep symptoms 50 Symptom-to-FRU index LCD-related symptoms ThinkPad T60 and T60p (15.4-inch widescreen) 51 XGA, WXGA 5 6 6 WXGA+, SXGA+, WSXGA+ 5 8 10 UXGA, WUXGA, QXGA 5 13 13 Intermittent problems 52 Undetermined problems Symptom-to-FRU index FRU replacement notices ThinkPad T60 and T60p (15.4-inch widescreen) 53 (Cross-section) Screw notices 90degrees more Restoring the serial number of the system unit 54 Retaining the UUID Reading or writing the ECA information FRU replacement notices ThinkPad T60 and T60p (15.4-inch widescreen) 55 Removing and replacing a FRU 56 Removing and replacing a FRU 1010 Battery pack ThinkPad T60 and T60p (15.4-inch widescreen) 57 1 2 1020 Ultrabay Slim device Removing and replacing a FRU 58 For access, remove this FRU: ThinkPad T60 and T60p (15.4-inch widescreen) 59 (continued) 1 Hard disk drive screw, nylon-coated (1) Black 0.167 Nm When installing: Make sure that the hard disk drive connector is attached firmly. Removing and replacing a FRU 60 1040 Palm rest or palm rest with fingerprint reader For access, remove this FRU in order: ThinkPad T60 and T60p (15.4-inch widescreen) 61 (continued) (4) Removing and replacing a FRU 62 ThinkPad T60 and T60p (15.4-inch widescreen) 63 1050 DIMM For access, remove these FRUs in order: v 1010 Battery pack on page 57 64 Removing and replacing a FRU 1060 Keyboard For access, remove these FRUs in order: v 1010 Battery pack on page 57 ThinkPad T60 and T60p (15.4-inch widescreen) 65 (1) 1 Removing and replacing a FRU 66 1070 Modem daughter card (MDC-1.5) ThinkPad T60 and T60p (15.4-inch widescreen) 67 1 M2 3 mm, small-head, nylon-coated (2) Silver 0.167 Nm Turn the card over 3 , and detach the modem connector 4 . Removing and replacing a FRU 68 1080 PCI Express Mini Card for 802.11 a/b/g wireless LAN 2 M2 9.5 mm, flat-head, nylon-coated (2) Black 0.167 Nm ThinkPad T60 and T60p (15.4-inch widescreen) 69 Removing and replacing a FRU 70 1090 PCI Express Mini Card for 802.11 a/b/g/n wireless LAN 2 M2 9.5 mm, flat-head, nylon-coated (2) Black 0.167 Nm ThinkPad T60 and T60p (15.4-inch widescreen) 71 Removing and replacing a FRU 72 1100 Backup battery ThinkPad T60 and T60p (15.4-inch widescreen) 73 When installing: Make sure that the battery connector is attached firmly. 1110 Keyboard bezel 1 M2 14 mm, flat-head, nylon-coated (2) Black 0.167 Nm 74 Removing and replacing a FRU In step 2 , release the wireless antenna cables from the cable guide. ThinkPad T60 and T60p (15.4-inch widescreen) 75 76 1120 PCI Express Mini Card for wireless WAN ThinkPad T60 and T60p (15.4-inch widescreen) 77 2 M2 3 mm, small-head, nylon-coated (2) Silver 0.167 Nm 1130 Wireless WAN (AUX) antenna cable 1 M2 3 mm, small-head, nylon-coated (2) Silver 0.167 Nm (1.7 kgfcm) 78 Removing and replacing a FRU 1140 Speaker assembly ThinkPad T60 and T60p (15.4-inch widescreen) 79 (continued) 1 M2 3 mm, small-head, nylon-coated (3) Silver 0.167 Nm Removing and replacing a FRU 80 1150 Fan assembly ThinkPad T60 and T60p (15.4-inch widescreen) 81 (continued) 4 M2 9.5 mm, flat-head, nylon-coated (3) Black 0.167 Nm Removing and replacing a FRU 82 ThinkPad T60 and T60p (15.4-inch widescreen) 83 1160 CPU 84 Removing and replacing a FRU 1170 SIM card slot ThinkPad T60 and T60p (15.4-inch widescreen) 85 When installing: Make sure the connector 2 is attached firmly. 1180 LCD assembly 1 M2 9.5 mm, flat-head, nylon-coated (2) Black 0.167 Nm 86 Removing and replacing a FRU Step Screw (quantity) Color Torque 3 M2 5 mm, flat-head, nylon-coated (2) Black 0.167 Nm ThinkPad T60 and T60p (15.4-inch widescreen) 87 88 1190 Base cover and USB sub card with cable ThinkPad T60 and T60p (15.4-inch widescreen) 89 5 M2 3 mm, small-head, nylon-coated (1) Silver 0.167 Nm Removing and replacing a FRU 90 ThinkPad T60 and T60p (15.4-inch widescreen) 91 Removing and replacing a FRU 92 1200 Structure frame ThinkPad T60 and T60p (15.4-inch widescreen) 93 (continued) 1 M2 3 mm, flat-head, nylon-coated (1) Silver 0.167 Nm Remove the ac power jack cable a and the modem cable b . Removing and replacing a FRU 94 Remove the CPU support plate. 7 M2 5 mm, flat-head, nylon-coated (1) Black 0.167 Nm ThinkPad T60 and T60p (15.4-inch widescreen) 95 (continued) (continued) Removing and replacing a FRU 96 (continued) ThinkPad T60 and T60p (15.4-inch widescreen) 97 Removing and replacing a FRU 98 1210 System board, PC Card/ExpressCard slots assembly ThinkPad T60 and T60p (15.4-inch widescreen) 99 running. cd ef Removing and replacing a FRU 100 ThinkPad T60 and T60p (15.4-inch widescreen) 101 2010 LCD front bezel For access, remove this FRU: 102 Removing and replacing a FRU 2020 Inverter card For access, remove these FRUs in order: v 1010 Battery pack on page 57 ThinkPad T60 and T60p (15.4-inch widescreen) 103 2030 Bluetooth daughter card (BDC-2) For access, remove these FRUs in order: v 1010 Battery pack on page 57 104 When installing: Make sure that connector is attached firmly. Removing and replacing a FRU 2040 LCD panel, LCD cable, wireless LAN 3rd antenna, and hinges ThinkPad T60 and T60p (15.4-inch widescreen) 105 1 M2 3.5 mm, flat-head, nylon-coated (4) Black 0.167 Nm Removing and replacing a FRU 106 ThinkPad T60 and T60p (15.4-inch widescreen) 107 (continued) Remove the LCD cable assembly ( c ) from the LCD panel. c 2050 Wireless WAN antenna cable (MAIN) 108 Removing and replacing a FRU 2060 LCD rear cover and wireless LAN antenna cables ThinkPad T60 and T60p (15.4-inch widescreen) 109 Locations Front view 110 Locations Rear view ThinkPad T60 and T60p (15.4-inch widescreen) Bottom view Locations Parts list Overall c 112 d a b (continued) 42W2209 R ** No. FRU FRU no. RoHS ID 42W2211 R ** 114 No. FRU FRU no. RoHS ID ThinkPad T60 and T60p (15.4-inch widescreen) No. FRU FRU no. RoHS ID Parts list 116 No. FRU FRU no. RoHS ID ThinkPad T60 and T60p (15.4-inch widescreen) No. FRU FRU no. RoHS ID Parts list 118 No. FRU FRU no. RoHS ID ThinkPad T60 and T60p (15.4-inch widescreen) 13N5108 R * 15 Hard disk drive cover assembly (15.4-in.) 42W2609 R * No. FRU FRU no. RoHS ID Parts list 120 No. FRU FRU no. RoHS ID ThinkPad T60 and T60p (15.4-inch widescreen) 121 42W2617 R N Taiwan v 8742-CTO, xxV 42W2618 R N Taiwan v 8743-CTO, xxV 42W2619 R N Taiwan v 8744-CTO, xxV Parts list 122 No. FRU FRU no. RoHS ID ThinkPad T60 and T60p (15.4-inch widescreen) 123 42W2203 R N 42W2205 R N 42W2207 R N Parts list 124 No. FRU FRU no. RoHS ID ThinkPad T60 and T60p (15.4-inch widescreen) 125 41W1138 R N 41W1327 R N 41W1409 R N Parts list 126 Page LCD FRUs Parts list 128 15.4-in. WXGA TFT ID ThinkPad T60 and T60p (15.4-inch widescreen) 129 42W2605 R N 42W2606 R N Parts list 130 No. FRU FRU no. RoHS ID ThinkPad T60 and T60p (15.4-inch widescreen) 131 93P4387 R N 42W2635 R * 41W1338 R N Parts list 132 15.4-in. WSXGA+ TFT ID ThinkPad T60 and T60p (15.4-inch widescreen) 133 42W2605 R N 42W2606 R N Parts list 134 No. FRU FRU no. RoHS ID ThinkPad T60 and T60p (15.4-inch widescreen) 135 93P4385 R N 42W2778 R N 93P4387 R N Parts list 136 No. FRU FRU no. RoHS ID ThinkPad T60 and T60p (15.4-inch widescreen) 137 39T0497 R N Keyboard Parts list 138 Recovery discs Windows XP Professional CDs ThinkPad T60 and T60p (15.4-inch widescreen) 139 Parts list 140 Windows XP Home Edition CDs Windows Vista Home Basic (32 bit) DVDs 142 ID Parts list Windows Vista Business (32 bit) DVDs ThinkPad T60 and T60p (15.4-inch widescreen) 143 ID Windows Vista Ultimate (64 bit) DVDs 144 ID Parts list Miscellaneous parts ID ThinkPad T60 and T60p (15.4-inch widescreen) 145 42W2604 R N 42W2602 R N AC adapters 146 Parts list Common parts list Tools ThinkPad T60 and T60p (15.4-inch widescreen) 147 Power cords 148 (Longwell) P/N (Volex) RoHS ID For 3-pin power cords: Notices ThinkPad T60 and T60p (15.4-inch widescreen) 149 Notices Trademarks Notices 150