Manuals / Micron Technology / Household Appliance / Fan

Micron Technology Turbofan instruction manual Pressure Gauge

Models: Turbofan

1 28

Download 28 pages 37.76 Kb

Page 14

PRESSURE GAUGE

				DRAFT
PRESSURE GAUGE		FLOW CONTROL		CHECK	VALVE
SIDE FILTER	ON/OFFVALVE		RELIEF	VALVE
PRESSURE	PUMP	OIL RESERVOIR	RELIEF	VALVE	HEADSSPRAYCONNECTED	INPARALLEL
FILLER/BREATHER	FILTER	OIL RESERVOIR			HEADSSPRAYCONNECTED	INPARALLEL
		SUCTION STRAINER
	RETURN

Figure 6. Typical self-contained hydraulic system

13

Image 14

Micron Technology Turbofan instruction manual Pressure Gauge

Contents

Micron Sprayers Limited Instruction manual and installation guideTURBOFAN Bromyard Industrial EstateCONTENTS 1.0 INTRODUCTION DRAFTFigure 1. Turbofan spray head 2.0 SPECIFICATIONDRAFT 3.0 TEN KEY POINTS FOR USERS DRAFT4.1Mounting of Sprayheads 4.0 INSTALLATIONDRAFT DRAFT 4.1.2Spacing of Sprayheads4.2Hydraulic System 4.2.1Hydraulic ConfigurationDRAFT 4.1.3Angle of Sprayheads DRAFT 4.2.2Parallel Connection 4.2.3Series Connection4.2.5Hydraulic Pressure and Hose Size Selection DRAFT4.2.4Hydraulic Oil Flow hydraulic hoses TABLE 1 – Pressure drop alongDRAFT HOSE SIZEPage 4.2.9Speed Regulation DRAFT 4.2.7System Protection4.2.8 Pressure Surge Prevention 4.2.10 Hydraulic OilPRESSURE GAUGE DRAFT OPEN CENTRE SYSTEMCLOSED CENTRE SYSTEM PRESSURE GAUGE PRESSURE LINE FROM TRACTORDRAFT 4.2.13Filter 4.3Spray LiquidIf a new sprayer is being designed or an original pump is to be replaced, it is suggested that a diaphragm or centrifugal type is chosen. This should be able to provide a pressure of about 1 – 3 bar 15 – 45 psi and should be capable of delivering the maximum flow rate of the sprayer plus the flow required for tank agitation if a mechanical agitator is not used. An output of 60 l/min is satisfactory for most low volume sprayers without mechanical agitation DRAFTDRAFT 4.4Testing5.2Calibration Procedure 5.1 Daily inspection5.4Sequence of Operation 6.0 HEALTH AND SAFETYDRAFT 5.5After Use7.1 Application Rate 7.0 CALIBRATION AND ADJUSTMENTDRAFT DRAFT Figure 9. Coverage of sprayerTable 2 – Coverage of sprayer in ha/min 16 l/min from sprayer DRAFTExample OutputEach day after spraying 8.0 MAINTENANCEDRAFT 8.2 Dismantling of SprayheadDRAFT 2.Remove atomiser 1 by unscrewing screwDESCRIPTION DRAFTPART NO MICRON ATOMISER PARTS TBF/003TURBOFAN PARTS DIAGRAM DRAFTA E B D C APPENDIX A