Multiquip ga-9.7HE manual GA9.7HE- nameplate and decalS Assy, Operating Instructions

GA9.7HE— nameplate and decalS ASSY.

	WARNING			DANGER		CAUTION				OPERATING INSTRUCTIONS
					OPERATE AT				1.	Before starting check the oil and fuel level.
	To avoid injury,			Do not touch output terminals or	3600 RPM ONLY
				internal wiring while unit is operating.					2.	Switch the circuit breaker to the “OFF” position.
	you MUST read		S-4985Turn off power before servicing.		(FULL THROTTLE)				3.	Pull the choke knob.
	and understand	ELECTRICAL		Only qualified personnel should	DAMAGE MAY RESULT IF				4.	Turn the operation switch to the “ON” position
	operator’s manual	SHOCK		install, use or service this	OPERATED AT LOWER SPEEDS
1		HAZARD		equipment.						and push the start button to start the engine.	2
	before using this
	machine.			WARNING	WARNING				5. After the engine starts, gradually push in the choke knob.
	This machine to								6.	Run the generator for 3-5 minutes without load.
	be operated by			Only operate machine in well ventilated	B e f o r e c o n n e c t i n g t h i s				7.	Check for any abnormal noise or smell.
	qualified				g e n e r a t o r	t o a n y b u i l d i n g ’ s			8.	Switch the circuit breaker to the “ON” position.
				areas.	e l e c t r i c a l	s y s t e m , a l i c e n s e d
	personnel only.			DO NOT inhale exhaust gases.	e l e c t r i c i a n m u s t i n s t a l l			a n	9.	When stopping, cut-off the load and allow the unit
					i s o l a t i o n ( t r a n s f e r ) s w i t c h .					to cool for 2-3 minutes before stopping engine.
	Ask for training		S-4984	Only qualified personnel should
				Only qualified personnel should	S e r i o u s i n j u r y		o r d e a t h	m a y	10.Turn the operation switch to the “OFF” position.
	as needed.	DANGEROUS		install, use or service this	r e s u l t w i t h o u t		t h i s t r a n s f e r
				install, use or service this
		GAS		equipment.equipment.	s w i t c h .
							A91110010			D25200040B

CAUTION

HOT PARTS can burn skin.

DO NOT touch until the lamp has sufficiently cooled.

B90400030

	AC CIRCUIT BREAKER			120	ON	ON		9700
				V 240
							GA-9.7HE
					OFF	OFF
					IDLE CONTROL	OPERATION	START
for 120V	for 120V	for 240V for 120/240V		AC VOLTMETER	SWITCH	SWITCH	BUTTON
15A	30A	20A	30A				OFF	OFF
			120V		240V	120/240V
							35A	35A
							AC CIRCUIT
							BREAKER
							(for main)

12

S-1123

WARNING

Operation of this equipment may create sparks that can start fires around dry vegetation.

A spark arrestor may be required. The operator should contact local fire agencies for laws or regulation relating

to fire prevention requirements. A91110010

S/N 5619690 AND ABOVE

3

4

11

10 OIL DRAIN

DANGER

THE POSSIBILITY EXISTS OF ELECTROCUTION IF GENERATOR/WELDER IS NOT PROPERLY GROUNDED. ALWAYS CONNECT EARTH GROUND (GROUND ROD) TO GENERATOR GROUND POINT.

6000

GROUND SCREW

GROUND

CABLE

#8 MINIMUM

	GROUND ROD
	FOR EARTH
	GROUND
	CONNECT TO
	BUILDING
	GROUND
	IF REQUIRED
FOR FURTHER GROUNDING	8 FT. MINIMUM
INSTRUCTIONS, READ MANUAL
REFERENCE
NEC 250-52(C)

D9531100104

DANGER

Using a generator indoors CAN KILL YOU IN MINUTES.

Utilser un générateur à l’ intérieur VOUS TUERA EN QUELQÙES MINUTES.

Exhaust contains carbon monoxide, a poison gas you cannot see or smell. Les gaz d’ échappement contiennent du monoxyde de carbon, un gaz toxique invisible et inodore.

NEVER use in enclosed or partially	ONLY use outdoors and away from
	open windows, doors, and vents.
enclosed areas.
	Utilisation UNIQUEMENT à l’ extér leur
Utilisation INTERDITE dans un
espace clos ou partiellement clos.	portes et trous d’ aération
		A90400001

5

					6
		CAUTION
9	Before starting the engine, check that the oil		OIL LEVEL GAUGE
	level is within the indicated operating range.		H
	If the level is above the H mark or below
	the L mark, it is important to correct before
	operating to avoid damage.		L		9700
				GA-9.7HE
		DANGER EXPLOSIVE GASES
		Cigarette flames or sparks could cause battery to explode. Always
		shield eyes and face from battery. Do not charge or use booster cables
		or adjust post connections without proper instructions and training.
8		KEEP VENT CAPS TIGHT AND LEVEL
		POISON CAUSES SEVERE BURNS
		Contains sulfuric acid. Avoid contact with skin, eyes or clothing. In
		event of accident flush with water and call a physician immediately.			7
		KEEP OUT OF THE REACH OF CHILDREN		FUEL DRAIN

page 36 — GA9.7HE 60 hz gENERATOR• operation and parts manual — rev. #1 (04/29/10)