Multiquip MVH-304DSB - PRE-INSPECTION, Danger, Oil Type, Explosive Fuel, Before Starting

CAUTION :

NEVER operate the compactor in a confined area or enclosed area structure that does not provide ample free flow of air.

ALWAYS wear approved eye and hearing protection before operating the compactor.

Before Starting

1.Read safety instructions at the beginning of manual.

2.Familiarize yourself with the operating and control elements of the machine

and the working environment. This includes obstacles in the working area, bearing capacity of the ground and the necessary safety provisions.

3.Check the air filter for dirt and dust. If air filter is dirty, replace air filter with a new one as required.

4.Check fastening nuts and bolts for tightness. Loose threads may cause damage to the machine when vibrating.

5. Understand the geographical features and regulations ofthe job site.

6.Clean the compactor, removing dirt and dust. Particularly, the bottom of the plate, engine cooling air inlet.

Checking Engine Oil Level

1.Make sure that the machine is situated in a flat surface so that level measurements will be accurate.

2.Pull out the dipstick from the oil tank (Figure 5).

CAUTION :

DO NOT overfill oil tank. This could cause oil leaks and sluggish operation. Clean cap and surrounding area before opening to prevent dirt from entering tank.

Figure 5. Oil Dipstick Removal

MVH-304DSB — PRE-INSPECTION

3.If the oil level is low, fill to the edge of the oil filler hole with the recommended oil type (Table 4). Maximum oil capacity is 1.74 quarts (1.65 liters).

Table 4. Oil Type

Season	Temperature	Oil Type
Summer	25°C or Higher	SAE 10W-30
Spring/Fall	25°C~10°C	SAE 10W-30/20
Winter	0°C or Lower	SAE 10W-10

Explosive Fuel

DANGER

Diesel fuel is highly flammable and can be dangerous if mishandled. DO NOT smoke while refueling. DO NOT attempt to refuel the compactor if the engine is hot! or running.

Checking The Fuel

1.Remove the fuel cap located on top of fuel tank.

2.Visually inspect to see if fuel level is low. If fuel is low, replenish with diesel fuel (Figure 6).

3.When refueling, be sure to use a strainer for filtration. DO NOT top-off fuel. Wipe up any spilled fuel.

Figure 6. Refueling

DANGER

Fuel spillage on a hot engine can cause a fire or explosion. If fuel spillage occurs, wipe up the spilled fuel completely to prevent fire hazards. NEVER! smoke around or near the compactor.

PAGE 16 — MQ-MIKASA MVH-304DSB PLATE COMPACTOR — PARTS & OPERATION MANUAL — REV. #2 (11/16/05)