Multiquip MVH-304GHB PRE-INSPECTION, Before Starting, Engine Oil Check, Checking The Fuel

CAUTION

NEVER operate the compactor in a confined area or enclosed area structure that does not provide ample free flow of air.

ALWAYS wear approved eye and hearing protection before operating the compactor.

Before Starting

1.Read safety instructions at the beginning of manual.

2.Familiarize yourself with the operating and control elements of the machine and the working environment. This includes obstacles in the working area, bearing

capacity of the ground and the necessary safety provisions.

3.Check the air filter for dirt and dust. If air filter is dirty, replace air filter with a new one as required.

4.Check carburetor for external dirt and dust. Clean with dry compressed air.

5.Check fastening nuts and bolts for tightness.

6. Understand the geographical features and regulations ofthe job site.

7.Clean the compactor, removing dirt and dust. Particularly, the bottom of the plate, engine cooling air inlet.

Engine Oil Check

1.To check the engine oil level, place the compactor on secure level ground with the engine stopped.

2.Remove the filler dipstick from the engine oil filler hole (Figure 5) and wipe clean

MVH-304GHB — PRE-INSPECTION

Table 4. Oil Type

Season	Temperature	Oil Type
Summer	25°C or Higher	SAE 10W-30
Spring/Fall	25°C~10°C	SAE 10W-30/20
Winter	0°C or Lower	SAE 10W-10

Figure 6. Engine Oil Dipstick (Oil Level)

Explosive Fuel

DANGER

Motor fuels are highly flammable and can be dangerous if mishandled. DO NOT smoke while refueling. DO NOT attempt to refuel the compactor if the engine is hot! or running.

Checking The Fuel

1.Remove the fuel cap located on top of fuel tank.

2.Visually inspect to see if fuel level is low. If fuel is low, replenish with unleaded gasoline (Figure 7).

3.When refueling, be sure to use a strainer for filtration. DO NOT top-off fuel. Wipe up any spilled fuel.

Figure 5. Engine Oil Dipstick (Removal)

3.Insertandremovethedipstickwithoutscrewingitintothefiller neck. Check the oil level shown on the dipstick.

4.If the oil level is low (Figure 6), fill to the edge of the oil filler hole with the recommended oil type (Table 4).Maximum oil capacity is 1.16 quarts (1.1 liters).

DANGER

Figure 7. Refueling

Fuel spillage on a hot engine can cause a fire or explosion. If fuel spillage occurs, wipe up the spilled fuel completely to prevent fire hazards. NEVER! smoke around or near the compactor.

PAGE 16 — MQ-MIKASA MVH-304GHB PLATE COMPACTOR — PARTS & OPERATION MANUAL — REV. #0 (11/25/02)