basic engine
2 | 3 | 4 |
11
ROBIN DIESEL
11
5
scs
1 | ROBIN |
DIESEL |
6
10 9 8 7
FRONT VIEW | REAR VIEW |
Figure 3. Robin D1B40T92040 Diesel Engine Components
ENGINE COMPONENTS
Figure 3 illustrates the location of the major components for the ROBIN D1B40T92040 diesel engine. The function of each component is described below
1.Recoil Starting Handle (pull rope) – Type of engine starting method. Alternate type would be electric start (ignition key).
2.Fuel Filler Cap/Fuel Tank – Remove this cap to add diesel fuel to the fuel tank. Make sure cap is tighten securely. DO NOT over fill. Fuel tank capacity is 5.3 quarts (5.0 liters)..
3.Engine Lifting Straps/Cover – Remove the air cleaner cover, then lift this cover (the one with decals on it) to gain access to the engine lifting straps.
4.Air Cleaner/Cover – Prevents dirt and other debris from entering the fuel system. Remove
5.Speed Control Lever – This lever is connected to the throttle control which is located on the compactor handle bar. This lever to controls engine speed.
6.Oil Filler Cap / Dipstick – Remove this cap to add oil to the engine crankcase. Read dipstick to determine if oil level is low. DO NOT over fill lever to control engine speed. Engine oil capacity is 1.6 quarts (1.55 liters).
7.Engine Motor Mounts – Secure these engine mounts to the compactor frame. Tighten securely.
8.Oil Suction Filter – Remove this bolt to gain access to the internal oil suction filter. Service the oil suction filter as recommended in the maintenance section of this manual.
9.Oil Drain Plug – Unscrew plug to drain oil from engine crankcase. Dispose of oil in a safe manner.
10.Crankshaft – Connect this shaft to the input of the transmission.
11.Muffler – Used to reduce noise and emissions.
12.Engine Nameplate – Contains information about the engine.
mvh406dsz/dsCPAs pLATE COMPACTOR • operation and parts manual — rev. #7 (02/28/14) — page 15
