Manuals
/
New Buck Corporation
/
Household Appliance
/
Gas Heater
New Buck Corporation
1127B manual Blown Up View Of Heater, Fan, Motor, And All Removable Parts
Models:
1127B
1
40
43
43
Download
43 pages
22.24 Kb
36
37
38
39
40
41
42
43
<
>
Troubleshooting
Install
Repair Parts
Parts list
Wiring Diagram
Log Placement For
Warranty
Connecting To A Gas Supply
Problem
Blown Up View Of Burner Assembly
Page 40
Image 40
BLOWN UP VIEW OF HEATER, FAN
MOTOR, AND ALL REMOVABLE PARTS
38
Page 39
Page 41
Page 40
Image 40
Page 39
Page 41
Contents
NEW BUCK CORPORATION
MODEL 1127B VENT-FREEGAS HEATER
Manufacturer NEW BUCK CORPORATION P.O. Box
8000 Highway 226 South Spruce Pine, NC
Page
TABLE OF CONTENTS
Page
SAFETY INFORMATION WARNINGS
Do not try to light any appliance
21. . ”WARNING Failure to keep the primary air openings of the burners clean may result in sooting and property damage.”
PRODUCT IDENTIFICATION
PRODUCT FEATURES
UNPACKING
SAFETY DEVICE
PIEZO IGNITION SYSTEM
NOTE FOR GARAGE INSTALLATION
MINIMUM CLEARANCES TO COMBUSTIBLE CONSTRUCTION
For convenience and efficiency, install heater
INSTALLATION
1.Wall Mounted
2.Freestanding heater with optional pedestal
3.Freestanding with optional wooden mantel
CLEANING INFORMATION
FREESTANDING WITH OPTIONAL PEDESTAL INSTALLATION
FREESTANDING OPTIONAL WOODEN MANTEL INSTALLATION
OPTIONAL “L” BRACKETS 2 AND SCREWS 2 PRO
PRODUCING ADEQUATE VENTILATION
DETERMINING FRESH-AIRFLOW FOR HEATER LOCATION
Vent-freeheater
VENTILATION AIR
VENTILATION AIR FROM INSIDE BUILDING
VENTILATION AIR FROM OUTDOORS
GAS CONNECTION
FLAME
Propane Supply Tank
CONNECTING TO A GAS SUPPLY
External Regulator Vent Pointing Down
Installation must include manual shutoff valve and plugged 1/2 NPT tap. Locate NPT tap within reach for test gauge hook-up.NPT tap must be upstream from unit
GAS PRESSURE CHECK
Logs are shipped secured in unit
LOG PLACEMENT FOR
Front View of Logs
LIGHTING INSTRUCTIONS MODULATING VALVEMAXITROL
FOR YOUR SAFETY, READ BEFORE LIGHTING
OPERATING INSTRUCTIONS
LIGHTING INSTRUCTIONS
to IGNITE and
for “LOW”
for “HIGH”
IGNITER ELECTRODE THERMO-COUPLE
TO TURN OFF GAS TO APPLIANCE
O.D.S PILOT BURNER
MANUAL LIGHTING PROCEDURE
THERMOSTAT CONTROL OPERATION
FLAME CHECK
BURNER FLAME PATTERN
CORRECT FLAME PATTERN AT HIGH POSITION
Figure 1815 - Correct Burner Flame Pattern
INCORRECT FLAME PATTERN AT HIGH POSITION
WIRING DIAGRAM
POWER CORD
MOTOR
JUMPERTHERMOSTAT
REPAIR PARTS
SERVICING
IMPORTANT SAFEGUARDS
CLEANING
TROUBLE-SHOOTING
PROBLEM
SOLUTION
OBSERVED
POSSIBLE
1.Control knob is not fully pressed in
Delayed ignition of burner
1. Heater produces a clinking
TECHNICAL SERVICE
MODEL 1127 - MODULATING VALVE
PARTS LIST
BLOWN UP VIEW OF HEATER, FAN
MOTOR, AND ALL REMOVABLE PARTS
PARTS LIST
BURNER SYSTEM
BLOWN UP VIEW OF BURNER ASSEMBLY
LIMITED WARRANTY ON VENT-FREEGAS LOG HEATER
NEW BUCK CORPORATION
