Manuals
/
Pentair
/
Household Appliance
/
Water Heater
Pentair
CH installation manual A-13, Rev. C
Models:
CH
1
35
36
36
Download
36 pages
5.9 Kb
29
30
31
32
33
34
35
36
<
>
Troubleshooting
Specifications
Install
Parts list
pH Chart
Warranty
Maintenance
Electronic Ignition Wiring
Thermostat Adjustment
Indicator Light Description
Page 35
Image 35
NOTES
Rev. C
1-22-04
A-13
P/N 472128
Page 34
Page 36
Page 35
Image 35
Page 34
Page 36
Contents
MiniMax CH
OPERATION & INSTALLATION MANUAL
For Your Safety
FOR YOUR SAFETY - READ BEFORE OPERATING
Table of Contents
IMPORTANT NOTICES
Introduction
Pool and Spa Heaters
CODE REQUIREMENTS
PRODUCT IDENTIFICATION
WARRANTY INFORMATION
SAFETY RULES
Operation
Operation contd
FOR YOUR SAFETY READ BEFORE LIGHTING
LIGHTING INSTRUCTIONS
TO TURN OFF GAS TO HEATER
POWER THERMOSTAT SELECT SWITCH
OPERATING CONTROLS
Dual Temperature Control System
THERMOSTAT ADJUSTMENT
SPRING AND FALL OPERATION
Maintenance
MAINTENANCE INSTRUCTIONS
ENERGY SAVING TIPS
POOL AND SPA WATER
CHEMICAL BALANCE
pH Chart
pH Control Chart
Outdoor installation - with vent kit
Installation Instructions
SPECIFICATIONS
Outdoor installation - stackless
BELOW OR ABOVE POOL INSTALLATION
PLUMBING CONNECTIONS
PLUMBING
BELOW POOL INSTALLATION
Reversible Inlet/Outlet Connection
WATER CONNECTIONS
INSULATING THE HIGH LIMITS
When Reversing Heads on the MiniMax CH Heater
GAS LINE INSTALLATIONS
GAS CONNECTIONS
PROPANE 2 STAGE REGULATION
Installation contd
REGULATED MANIFOLD PRESSURE TEST
MINIMAX CH GAS PRESSURE REQUIREMENTS
Installation contd
VENTILATION
OUTDOOR INSTALLATION ONLY
OUTDOOR VENT CAP INSTALLATION
Remaining
Front
Water Connection
24 in
MiniMax heaters
INDOOR DRAFT HOOD INSTALLATION
STACK TYPE INDOOR DRAFT HOOD KIT
Air supply requirements below apply to all
MiniMax CH Millivolt Wiring Diagram
ELECTRICAL
Installation contd
Troubleshooting - General
470024
MINIMAX CH HEATER - ALL MODELS
INNER TOPS
Model No. Part No
DESCRIPTION
MiniMax CH Parts List
Not Shown
MiniMax CH Parts List, contd
DESCRIPTION
Rev. C
MiniMax CH 150 IID Model
APPENDIX
For Your Safety
FOR YOUR SAFETY - READ BEFORE OPERATING
WHAT TO DO IF YOU SMELL GAS
OPERATING INSTRUCTIONS
TO TURN OFF GAS TO APPLIANCE
FOR YOUR SAFETY READ BEFORE LIGHTING
TO TURN OFF GAS TO APPLIANCE
FOR YOUR SAFETY READ BEFORE LIGHTING
Safety Lockout
OPERATING INSTRUCTIONS
POWER LIGHT POWER
INDICATOR LIGHT DESCRIPTION
THERMOSTAT ADJUSTMENT
POWER THERMOSTAT SELECT SWITCH
HEAT HEAT
TROUBLESHOOTING CONTROLS
SERVICE SERVICE
THERMOSTAT CIRCUIT BOARD
TROUBLESHOOTING CONTROLS - Continued
Operation contd
Rev. C
ELECTRICAL, IID ELECTRONIC UNITS
REGULATED MANIFOLD PRESSURE TEST
MiniMax CH 150 IID Model
Installation contd
Electronic Ignition Wiring
Diagram
2 Wire Remote
Installation contd
REMOTE SWITCH DUAL THERM IID ONLY
3 Wire Remote
Model No. Part No
MINIMAX CH HEATER - 150 IID MODEL
A-10
INNER TOP
A-11
MiniMax CH Parts List - 150 IID Model
DESCRIPTION
A-12
MiniMax CH Parts List - 150 IID Model, contd
DESCRIPTION
Not Shown
Rev. C
A-13
Rev. C
SAVE THESE INSTRUCTIONS
Pentair Pool Products, Inc
1620 Hawkins Ave., Sanford, NC
