Exploded | Poulan 438371, 96192004602 specification

REPAIR PARTS SNOW THROWER - - MODEL NUMBER PR8P27ES (96192004602)

AUGER HOUSING / IMPELLER ASSEMBLY

			5
	11
	6		11
	6
15			7
15
14	11	16	8
	12		8
	12
4
13	11		17
	3 12		17
	3 12		10
			10
	1
	9		37
			2

33	37
33	32
34	30
31 31	30
31 31
	26	36
	29	20
	27	20
	28	23 22 21
	25

	24
	22 23
21	2 (EXPLODED)
	2 (EXPLODED)
19
	01.07.026-D

NOTE: All component dimensions given in U.S. inches. 1 inch = 25.4 mm

IMPORTANT: Use only Original Equipment Manufacturer (O.E.M.) replacement parts. Failure to do so could be hazardous, damage your snow thrower and void your warranty.

Page 22

Image 22

Poulan 438371, 96192004602 owner manual Exploded

Contents

Model Number Snow Thrower Safe Operation Practices for Walk-Behind Snow Throwers Table of Contents Parts Packed Separately in Carton Assembly / PRE-OPERATIONHOW to SET UP Your Snow Thrower Remove Snow Thrower from Carton Install Traction Drive Control ROD See Figs Install Speed Control ROD See FigsUnfold Upper Handle Install Auger Control ROD See Figs Install Discharge Chute / Chute Rotater Head See Fig Install Chute Deflector Remote Control See Figs Check Tire Pressure Primer OperationKnow Your Snow Thrower Ignition KEY Meets A.N.S.I. Safety Requirements Recoil auxiliary starter handle used for starting the engine To USE Choke Control See Fig HOW to USE Your Snow ThrowerStopping To Control Snow Discharge See Fig To Throw Snow See Fig Using the CLEAN-OUT Tool See FigPower Steering Operation See Fig To Move Forward and Backward See Fig Scraper BAR See Fig To Adjust Skid Plates See FigBefore Starting the Engine Check Engine OIL Level See Fig Before Stopping Snow Throwing TipsTo Start Engine If Recoil Starter has Frozen Before Each USE MaintenanceGeneral Recommendations Lubrication Cleaning Engine Chute Deflector Service and AdjustmentsTo Adjust Snow Thrower Height Shear Bolts See Fig To Replace Belts See Fig Carburetor To Adjust Cable Tension See FigTo Remove Wheels See Fig Engine Speed Fuel System StorageOther Engine OIL Troubleshooting Service Notes Exploded KEY Part Description Auger Bearing Auger HousingScraper BAR Bearing Plug Skid Plate LH Auger 27 LHAuger 27 RH Skid Plate RH POP Rivet Deflector SealKnob Black Chute Snow Shield 419822X431 Shield Retainer Strap KEY Part 419797X431 Loop Handle LHLoop Handle RH Lower Handle Knob RED SpacerRetainer Handle Knob Carriage Bolt 5/16-18 X 155377 NUT 5/16-18 169675 Headlight Bezel Wire HarnessConsole Panel Flood Headlight Repair Parts Snow Thrower - Model Number PR8P27ES Drive Wheel HUB Speed Selector AssemblyDrive Plate Assembly END Plate Axle Shaft Sprocket 436146X421 ENGINE, B&SFrame Engine Mounting Plate 428684 Wheel Lobe CoverWheel Driver Clutch Slide Cable Bracket LH Wheel Assembly LHCable Bracket RH Safety Ignition KEY 193071 DECAL, Danger 181037DECAL, DANGER, Deflector Service Notes Service Notes Service Notes Limited Warranty

2 (EXPLODED)