TROUBLESHOOTING CHART
| PROBLEM |
| CAUSE |
| CORRECTION | |
|
|
| ||||
|
|
|
|
|
|
|
| Poor grass | 1. | Engine speed too slow. |
| 1. | Place throttle control in |
| discharge |
|
|
|
| “FAST” position. |
|
| 2. | Travel speed too fast. |
| 2. | Shift to slower speed. |
|
| 3. | Wet grass. |
| 3. | Allow grass to dry before |
|
|
|
|
|
| mowing. |
|
| 4. | Mower deck not level. |
| 4. | Level mower deck. |
|
| 5. | Low/uneven tire air |
| 5. | Check tires for proper air |
|
|
| pressure. |
|
| pressure. |
|
| 6. | Worn, bent or loose blade. |
| 6. | Replace/sharpen blade. |
|
|
|
|
|
| Tighten blade bolt. |
|
| 7. | Buildup of grass, leaves |
| 7. | Clean underside of mower |
|
|
| and trash under mower. |
|
| housing. |
|
| 8. | Mower drive belt worn. |
| 8. | Replace mower drive belt. |
|
| 9. | Blades improperly installed. |
| 9. | Reinstall blades sharp edge |
|
|
|
|
|
| down. |
|
| 10. Improper blades used. |
| 10. Replace with blades listed in | ||
|
|
|
|
|
| this manual. |
|
| 11. Clogged mower deck vent |
| 11. Clean around mandrels to | ||
|
|
| holes from buildup of grass, |
|
| open vent holes. |
|
|
| leaves, and trash around |
|
|
|
|
|
| mandrels. |
|
|
|
|
|
|
|
|
|
|
| Headlight(s) not | 1. | Switch is “OFF”. |
| 1. | Turn switch “ON”. |
| working | 2. | Bulb(s) or lamp(s) burned out. |
| 2. | Replace bulb(s) or lamp(s). |
| (if so equipped) | 3. | Faulty light switch. |
| 3. | Check/replace light switch. |
|
| 4. | Loose or damaged wiring. |
| 4. | Check wiring and connections. |
|
| 5. | Blown fuse. |
| 5. | Replace fuse. |
|
|
|
|
|
|
|
| Battery will not | 1. | Bad battery cell(s). |
| 1. | Replace battery. |
| charge | 2. | Poor cable connections. |
| 2. | Check/clean all connections. |
|
| 3. | Faulty regulator |
| 3. | Replace regulator. |
|
|
| (if so equipped). |
|
|
|
|
| 4. | Faulty alternator. |
| 4. | Replace alternator. |
|
|
|
|
|
|
|
| Engine “backfires” | 1. | Engine throttle control not set |
| 1. | Move throttle control |
| when turning |
| between half and full speed |
|
| between half and full speed |
| engine “OFF” |
| (fast) position before stopping |
|
| (fast) position before |
|
|
| engine. |
|
| stopping engine. |
|
|
|
|
|
|
|
28
