Installation & Maintenance Manual | PVI Industries PV500-45U

INSTALLATION & MAINTENANCE MANUAL

TRICON® WATER HEATER

MODELS (40, 50, 75, 90, 100) L 125 A-PVIF

MODELS (50, 75, 90, 100) L (250, 300) A-PVIF

Installation and service must be performed by a qualified service installer, service agency or the gas supplier.

IMPORTANT: THIS MANUAL CONTAINS INFORMATION REQUIRED FOR INSTALLATION, OPERATION AND MAINTENANCE OF THIS EQUIPMENT. READ AND FOLLOW THE INFORMATION IN THIS MANUAL AND ALL OTHER PROVIDED INSTRUCTIONS, LABELS AND MARKINGS BEFORE INSTALLING, OPERATING OR SERVICING THIS UNIT.

TO THE INSTALLER: After installation, these instructions must be given to the equipment user or left near the appliance.

SPECIAL INSTRUCTIONS TO THE OWNER: Retain this manual for future reference. These instructions contain important information that will help you in maintaining and operating this appliance.

PVI INDUSTRIES, LLC - Fort Worth, Texas 76111 - Web www.pvi.com - Phone 1-800-433-5654

1

PV500-45U 06/12

Image 1

PVI Industries PV500-45U manual Installation & Maintenance Manual

Contents

Installation & Maintenance Manual Table of Contents Troubleshooting Guide Replacement Parts Operating and Safety ControlsTemptrac Electronic Controller Panel Remote Connections Terminal Strip Product Safety Information Safety Considerations Below scalding temperatures Standard Features and Equipment Series Series Series Checking Equipment Before You Install Water Heater InstallationCodes Electrical Requirements Clearances To Combustible Surfaces Service ClearancesGeneral Piping Guidelines Inlet and Outlet Connections PV500-45U 06/12 PV500-45U 06/12 Optional Condensate Neutralization System Inlet Pressure NAT. GAS GAS Supply and PipingConvert Fittings to Equivalent Straight Pipe Multiple Unit Installations GAS Piping Size Chart Single Unit Installation Suggested Pipe SizeNominal Iron Length of Pipe in Straight Feet Inches Combustion and Ventilation AIR Vertical or Horizontal Remote Air Duct Termination Duct Fitting Equivalent Length Duct Pipe Venting the Tricon VentingMaximum Category IV Vent Length Equivalent Length Combining Category IV Vents Vent Fitting Equivalent Length Vent Pipe Temperature and Pressure Relief Valve s Operating and Safety Controls Cathodic Protection High Water Temperature Limit ControlElectronic Low Water Cut-Off Optional SET Temptrac Electronic Controller PanelDown Clock To Change The Setpoint To View The SetpointTo Change Other Parameters Alarm Cause Results of Alarm Condition Message LED Display Alarm MessagesRecommended Action Remote Connections Terminal Strip Incoming 120VAC Sequence of Operation LED Indication Fault Mode Loss of Flame Signal Initial Startup Turn-on main gas shutoff valve PV500-45U 06/12 Gas Train Illustration for Models 65 through Gas Train Illustration for Models 40 through Problem Probable Cause Corrective Action Troubleshooting Guide Replacement Parts Replacement Parts Control Panel Contact factory for more information Burner Assembly Optional components may or may not be shown Item No Qty PVI Part No Description Contact factory for more information Periodic Maintenance PV500-45U 06/12 Recommended Maintenance Schedule PV500-45U 06/12 PV500-45U 06/12