Control Panel | PVI Industries PV500-45U guide

16.1 Control Panel

34

PV500-45U 06/12

Image 34

PVI Industries PV500-45U manual Control Panel

Contents

Installation & Maintenance Manual Table of Contents Temptrac Electronic Controller Panel Operating and Safety ControlsTroubleshooting Guide Replacement Parts Remote Connections Terminal Strip Safety Considerations Product Safety Information Below scalding temperatures Standard Features and Equipment Series Series Series Codes Water Heater InstallationChecking Equipment Before You Install Electrical Requirements General Piping Guidelines Service ClearancesClearances To Combustible Surfaces Inlet and Outlet Connections PV500-45U 06/12 PV500-45U 06/12 Optional Condensate Neutralization System Inlet Pressure NAT. GAS GAS Supply and PipingConvert Fittings to Equivalent Straight Pipe Nominal Iron Length of Pipe in Straight Feet Single Unit Installation Suggested Pipe SizeMultiple Unit Installations GAS Piping Size Chart Inches Combustion and Ventilation AIR Duct Fitting Equivalent Length Duct Pipe Vertical or Horizontal Remote Air Duct Termination Venting the Tricon VentingMaximum Category IV Vent Length Equivalent Length Vent Fitting Equivalent Length Vent Pipe Combining Category IV Vents Operating and Safety Controls Temperature and Pressure Relief Valve s Cathodic Protection High Water Temperature Limit ControlElectronic Low Water Cut-Off Optional Down Temptrac Electronic Controller PanelSET Clock To Change The Setpoint To View The SetpointTo Change Other Parameters Recommended Action LED Display Alarm MessagesAlarm Cause Results of Alarm Condition Message Remote Connections Terminal Strip Sequence of Operation Incoming 120VAC Loss of Flame Signal LED Indication Fault Mode Initial Startup Turn-on main gas shutoff valve PV500-45U 06/12 Gas Train Illustration for Models 40 through Gas Train Illustration for Models 65 through Troubleshooting Guide Problem Probable Cause Corrective Action Replacement Parts Replacement Parts Control Panel Contact factory for more information Burner Assembly Optional components may or may not be shown Contact factory for more information Item No Qty PVI Part No Description Periodic Maintenance PV500-45U 06/12 Recommended Maintenance Schedule PV500-45U 06/12 PV500-45U 06/12