Raypak 504 thru 2004 Heat Exchanger Jacket Operating Controls Safeties, Gas Train Other, Boilers

HEAT EXCHANGER

JACKET

OPERATING CONTROLS

SAFETIES

GAS TRAIN

OTHER

	MVB
			Water Heaters		Boilers
			(Type WH)		(Type H)
ASME, National Board Registered, 160 PSI		• HLW Stamp			N/A
		• H Stamp	N/A	
Heat Exchanger Tubes		• Copper		
		• Cupro Nickel		
Bronze Headers				
Cast Iron Headers			N/A	
Pressure Relief Valve		• 60 PSI		
		• 125 PSI		
		• 30, 45, 75, 150 PSI		
Temperature & Pressure Gauge				
Pump		• 120V, Single-Phase		
Indoor/Outdoor Certified				
Vent Terminal		• Outdoor		
		• Through-the-Wall		
Fully-Enclosed Controls				
Combustible Floor Rated				
120V Power Supply with 120V/24V Transformer				
On/Off Switch				
Programmable Pump Time Delay, Single-Phase		• Included in TempTracker Mod Controller		
Terminal Block Connections		• Enable / Disable		
		• External Interlocks		
		• 0-10 VDC Setpoint/Direct Drive Input (cat. I)		
12 Diagnostic Lights with 256-Event History				
Status Display Lights (4)				
Temperature Controller with 3 Water Sensors		• TempTracker Mod (up to 4:1 Turndown, cat. IV)		
		• Outdoor Reset Sensor	N/A	
Multiple Boiler Controller		• TempTracker Mod+, up to 16 boilers		
		• Y-200, up to 40 boilers (LonWorks optional)		
Hot Surface Ignition System		• 1-try (standard on cat. IV)		
		• 3-try (standard on cat. I)		
High/Low Gas Pressure Switches				
Blocked Vent and Air Pressure Switches				
High Limit Switch		• Manual Reset, Fixed		
		• Manual Reset, Adjustable		
		• Automatic Reset, Adjustable		
Low Water Cut-Off, 24V		• With Manual Reset and Test Buttons		
Flow Switch				
Modulating Combination Gas Valve				
Combustion Air Blower				
TruSeal Direct-Vent Ready				
Additional Safety Valve		• Motorized (externally mounted)		
		• Solenoid (externally mounted)		
CSA-Certified Efficiency		• Cat. IV - 87% at Full Fire		
		• Cat. I - 84% to 85% (see MBTUH table)		
Air Filter				
Alarm System				
CSD-1 / GE GAP Control System				
Low NOx		• Meets all current requirements		
Cold Water Start		• Prevents internal condensation on start-up		
Cold Water Run		• Prevents condensation in continuous low-temp operation 		
  = Standard	  = Optional

Raypak, Inc. • 2151 Eastman Avenue, Oxnard, CA 93030 • phone: (805) 278-5300 • fax: (800) 872-8725 • www.raypak.com

Cat. No. 3400.11E Effective 07-01-08 Replaces 11-1-07