Manuals / Reliance Water Heaters / Household Appliance / Water Heater

Reliance Water Heaters RUF 100 199 SERIES 100, RUF 100 199 SERIES 101 warranty

Models: RUF 100 199 SERIES 100 RUF 100 199 SERIES 101

1 36

Download 36 pages 16.01 Kb

Page 33

Image 33

NOTES:

Page 33

Image 33

Reliance Water Heaters RUF 100 199 SERIES 100, RUF 100 199 SERIES 101 warranty

Contents

GAS-FIRED POWER BURNER FOR DOMESTIC HOT WATER INSTALLATION OPERATION SERVICE MAINTENANCE LIMITED WARRANTYRUF 100 199 SERIES 100 AND COMMERCIAL GAS WATER HEATERFOREWORD RUF 100 199 ROUGH-IN-DIMENSIONSApprox InputFEATURES TABLE OF CONTENTSWATER TEMPERATURE CONTROL PAGEHIGH LIMIT SWITCH E.C.O INSTALLATION INSTRUCTIONSDISHWASHING MACHINE REQUIREMENT CIRCULATING PUMPCLEARANCES LOCATING THE HEATERAIR REQUIREMENTS HARD WATERMECHANICAL EXHAUSTING OF ROOM AIR UNCONFINED SPACEINSTALLATION REQUIREMENTS FOR THE COMMONWEALTH OF MASSACHUSETTS U.S. DIRECT VENT U.S. POWER VENTDIRECT VENT TERMINAL INSTALLATION INSTALLATION SEQUENCEDIRECT VENTING INSTALLATION SEQUENCE VERTICAL VENT TERMINAL INSTALLATIONVENT PIPE PREPARATION INSTALLATION OF VENT SYSTEMTable 2. VENT LENGTH TABLE NumberGAS PIPING CONTROLS AND SWITCHESBLOWER PROVER SWITCH BLOCKED OUTLET PROVER SWITCHCONNECTION OF GAS PIPE PURGING SYSTEM CONNECTIONSGAS METER SIZE - CITY GASES ONLY GAS PRESSURE REGULATIONHEATER WIRING USING THE ELECTRONIC CONTROLLER 1.Overview 2. Operating States 3. Adjusting the Operating Set PointACTION DISPLAY6. Access to the Current Fault or Alert 5. Fault and Alert ConditionsExample of a Fault Advanced Diagnostics Information 4. Changing the Display Units7. Viewing the Fault History PRIOR TO START UP8. Viewing Information About the Heater REQUIRED ABILITYADJUSTMENT PROCEDURE OPERATING INSTRUCTIONSInitial Start-up GENERAL INFORMATION MAINTENANCEPRECAUTIONS POWER BURNERFOR YOUR SAFETY READ BEFORE OPERATING OPERATINGINSTRUCTIONS TURNOFFOFFGASTOTOAPPLIANCE199 MODELS FLUSHING POWERED ANODE SYSTEMDRAINING SEDIMENT REMOVALRELIEF VALVE DRAIN VALVE AND ACCESS PANELSCIRCULATING PUMP VENT SYSTEMINSTALLATION DIAGRAMS ONE TEMPERATURE - ONE HEATER VERTICAL STORAGE TANK FORCED CIRCULATIONWITH OR WITHOUT BUILDING RECIRCULATION TWO TEMPERATURE - ONE HEATER HIGH TEMPERATURE INSTALL IN ACCORDANCE WITH LOCAL CODESWITH OR WITHOUT BUILDING RECIRCULATION PIPE RELIEF VALVE TO OPEN DRAINWITH OR WITHOUT BUILDING RECIRCULATION TWO TEMPERATURE - TWO HEATERS HIGH TEMPERATURETWO TEMPERATURE - THREE HEATERS TWO PRE-HEATERS/ONE BOOSTER HEATER WITH OR WITHOUT BUILDING RECIRCULATIONTWO TEMPERATURE - TWO HEATERS ONE PRE-HEATER/ONE BOOSTER HEATER WITH OR WITHOUT BUILDING RECIRCULATIONPIPE RELIEF VALVE TO OPEN DRAIN TWO TEMPERATURE - ONE HEATER HIGH TEMPERATURE WITH RECIRCULATION OF SANITIZING LOOPDANGER MANIFOLD KITS TROUBLE-SHOOTING CHECKLIST AND SERVICE INFORMATIONBURNER OPERATIONAL PROBLEMS NOT ENOUGH OR NO HOT WATERMOTOR WILL NOT RUN REPLACEMENT PARTSMOTOR RUNS, PREPURGE TIME ELAPSES BUT MAIN FLAME NOT ESTABLISHED MOTOR RUNS, BURNER LIGHTS MOMENTARILY THEN LOCKS OUTPage Page 4. SERVICE AND REPAIR EXPENSES MODEL RUF LIMITED WARRANTY6. CLAIM PROCEDURE KEEP THIS WARRANTY POSTED ADJACENT TO THE HEATER FOR FUTURE REFERENCE