L. | LED DISPLAY |
Red blinking (slow) | – | indicates check battery connection or |
|
| blown fuse |
Red blinking (fast) | – | indicates error, abort stage |
Red solid | – | charger is charging, current at maximum |
Yellow #1 solid | – | charger is charging, voltage >14.2 volts |
Yellow #1 blinking | – | desulfation mode |
Yellow #2 solid | – | charger is charging, constant voltage |
Green solid | – charger is in final | |
|
| 95% charged |
Green blinking | – | charge complete maintain stage |
NOTE: When both output leads are connected to one battery, only channel one will display the charge status of the battery.
M. | AUTOMATIC CHARGE MODE |
The automatic charger uses a
N. | DESULFATION MODE |
If the battery has been left discharged for an extended period of time, it may have become ‘SULFATED’. If the battery voltage is less than
12.2volts prior to being charged, and the voltage climbs rapidly when charging begins, the battery may be SULFATED. Under this condition, the charger enters DESULFATION MODE; this is indicated by the first YELLOW LED blinking. In DESULFATION MODE, the initial charging current is very small. The charger will stay in DESULFATION MODE for up to 24 hours, attempting to break down the sulfation. If the battery current increases to normal in this time, the charger will enter the normal AUTOMATIC MODE. If the current does NOT increase to normal, the charger will enter the ABORT state and will shut off. The rapid flashing of the RED LED indicates the ABORT state and the battery may need to be replaced. The charger will remain in abort until the AC power is removed.
O. | EXTENDED BATTERY STORAGE |
The charger will draw a small amount of current from the battery(ies), a few milliamps, when not charging or maintaining. If the battery(ies) are going to be stored for an extended period of time (several months) without being charged, it is best to disconnect the leads or remove the fuse to keep the charger from discharging the battery(ies) over time.
P. | MAINTENANCE / CLEANING INSTRUCTIONS |
Very little maintenance is required for the battery charger. Use common sense in wiping the charger clean and store in a clean, dry area.
1.After use, use a dry cloth to wipe all battery corrosion and other dirt or oil from terminals, cords, and the charger case.
2.Coil charger cords to prevent damage.
3.Have any cracked or frayed cords replaced by a qualified professional.
4.Store battery charger in a clean, dry area.
LIMITED WARRANTY
SCHUMACHER ELECTRIC CORPORATION, 801 BUSINESS CENTER DRIVE, MOUNT PROSPECT, ILLINOIS
Schumacher Electric Corporation warrants this battery charger for two years from date of purchase at retail against defective material or workmanship. If such should occur, the unit will be repaired or replaced at the option of the manufacturer. It is the obligation of the purchaser to forward the unit together with proof of purchase, transportation and/or mailing charges prepaid to the manufacturer or its authorized representative.
This limited warranty is void if the product is misused, subjected to careless handling, or repaired by anyone other than the manufacturer or its authorized representative.
The manufacturer makes no warranty other than this limited warranty and expressly excludes any implied warranty including any warranty for consequential damages.
THIS IS THE ONLY EXPRESS LIMITED WARRANTY AND THE MANUFACTURER NEITHER ASSUMES NOR AUTHORIZES ANYONE TO ASSUME OR MAKE ANY OTHER OBLIGATION TOWARDS THE PRODUCT OTHER THAN THIS EXPRESS LIMITED WARRANTY. THE MANUFACTURER MAKES NO WARRANTY OF MERCHANTABILITY OR FITNESS FOR PURPOSE OF THIS PRODUCT AND EXPRESSLY EXCLUDES SUCH FROM THIS LIMITED WARRANTY.
SOME STATES DO NOT ALLOW THE EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSEQUENTIAL DAMAGES OR LENGTH OF IMPLIED WARRANTY SO THE ABOVE LIMITATIONS OR EXCLUSIONS MAY NOT APPLY TO YOU.
THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS AND YOU MAY ALSO HAVE OTHER RIGHTS, WHICH VARY FROM STATE TO STATE.
4