Schumacher SE-4225 owner manual Before Returning for Repairs

PROBLEM	POSSIBLE CAUSE	REASON/SOLUTION
Charger will not turn on	AC outlet is dead.	Check for open fuse or
when properly connected.		circuit breaker supplying AC
		outlet.
	Poor electrical connection.	Check power cord and
		extension cord for loose
		fitting plug.
The battery is connected	Clips are not making a	Check for poor connection
and the charger is on, but	good connection.	at battery and frame. Make
is not charging.		sure connecting points are
		clean. Rock clips back and
		forth for a better connection.
The measured current is	The charger reached the	No problem, this is a normal
much lower than what was	maximum voltage and is	condition.
selected.	reducing the current.

17.BEFORE RETURNING FOR REPAIRS

17.1When a charging problem arises, make certain that the battery is capable of accepting a normal charge. Use a good battery to double check all connections, AC outlet for a full 120-volts, charger clips for correct polarity and the quality of the connections from the cables to the clips and from the clips to the battery system. The clips must be clean.

17.2When a battery is very cold, partially charged or sulfated, it will not draw the full rated amperes from the charger. It is both dangerous and damaging to a battery to force higher amperage into it than it can effectively use in recharging.

17.3When an UNKNOWN OPERATING PROBLEM arises, please read the complete manual and call the customer service number for information that will usually eliminate the need for return.

If the above solutions do not eliminate the problem or for information about troubleshooting

or replacement parts, call toll-free from anywhere in the U.S.A.

1-800-621-5485

7:00 am to 5:00 pm Central Time Monday thru Friday

18.LIMITED WARRANTY

SCHUMACHER ELECTRIC CORPORATION, 801 BUSINESS CENTER DRIVE, MOUNT PROSPECT, IL 60056-2179, MAKES THIS LIMITED WARRANTY TO THE ORIGINAL RETAIL PURCHASER OF THIS PRODUCT. THIS LIMITED WARRANTY IS NOT TRANSFERABLE OR ASSIGNABLE.

Schumacher Electric Corporation (the “Manufacturer”) warrants this battery charger for 3 years from the date of purchase at retail against defective material or workmanship that may occur under normal use and care. If your unit is not free from defective material or workmanship, Manufacturers obligation under this warranty is solely to repair or replace your product, with a new or reconditioned unit, at the option of the Manufacturer. It is the obligation of the purchaser to forward the unit, along with mailing charges prepaid

to the Manufacturer or its authorized representatives in order for repair or replacement to occur.

• 14 •