WARNING
Improper installation, adjustment, alteration, service or mainte- nance can cause DEATH, SERIOUS BODILY INJURY OR PROP- ERTY DAMAGE. Refer to this manual for assistanceor consult
your local SearsService Center for further information.
WARNING
At the time of manufacture this water heater was equipped
with a temperature-pressure relief valve. For protection against excessive pressures and temperatures in this water heater, install temperature-pressure protective equipment required by local codes, but not lessthan a combination tem- perature-pressure rellef valve certified by nationally recog- nized tesh_nglaboratory that maintains periodic inspection of production Of listed equipment or materials, as meeting the
requirements for Relief Valves and Automatic Gas Shutoff Devices for Hot Water Supply Systems,the latest edition ANSI Z21.22. This valve must be marked with a maximum set pres- sure not to exceed the marked hydrostatic working pressure of the water heater (150 lbs./sq, in.). The relief valve must be
marked with a discharge capacity not less than the water heater Btu input rate as shown on the model rating plate. Install the temperature-pressure relief valve directly into the firing of the water heater. Position the valve downward and
provide tubing so that any discharge will exit only within 6 inches above, or at any distance below the structural floor. Be certain that no contact is made with any live electrical part. The discharge opening must not be blocked or reduced in size
under any circumstances. Excessivelength, over 15 feet, or use of more than two elbows can cause restriction and reduce the
discharge capacity of the valve.
No valve or other obstruction is to be placed between the
relief valve and the tank;. Do not connect tubing directly to discharge drain unlessa 6'air gap is provided. To prevent bod-
ily iniury, hazard to life, or damage property, the relief valve must be allowed to discharge water in quantities should cir- cumstancesdemand. If the discharge pipe is not connected to a drain or other suitable means, the water flow may cause property damage.
The Discharge Pipe:
-Must not be smaller in size than the outlet pipe size of the valve, or have any reducing couplings or other restriction.
-Must not be plugged or blocked.
-Must be of maten_al listed for hot water distribution.
-Must be installed so as to allow complete drainage of both the temperature-pressure relief valve, and the discharge pipe.
-Must terminate at an adequate drain.
-Mustnot have any valve between the relief valve and tank.
WARNING
A fire can start if combustible materials such as clothing, clean-
ing materials, or flammable liquids are placed against or next to the water heater.
WARNING
WATER HEATERSEQUIPPED FOR ONE TYPE GAS ONLY: This
water, heater is equipped for one type gas onl)_.Check the rat- mg plate near the gas control valve for the correct gas. DO
NOT USE THIS WATER HEATER WITH ANY GAS OTHER THAN THE ONE SHOWN ON THE MODEL RATING PLATE.
Failure to use the correct gas can cause problems which can result in DEATH, SERIOUS BODILY INJURY, OR PROPERTY DAMAGE. tf you have any questionsor doubts consult your gas supplier or local utility.
WARNING
INSTALLATION IN RESIDENTIAL AREAS WHERE FLAMMABLE J
LIQUIDS (VAPORS) ARE LIKELYTO BE PRESENTOR STORED (GARAGES; STORAGE, AND UTILITY AREAS, ETC): Flammable liquids (such as gasoline, solvents, propane (LP) or butane, etc.), all of which emit flammable vapors, may be improperly stored or used in such areas. The gas water heater
ilot hght or main burner can ignite such.vap°rs" The resulting I_ashbackand fire can cause death or serious burns to anyone
in the area, as well as property damage.
If installation in such areas is your only option, then the instal- lation must be accomplished in a way that the pilot flame and main burner flame are elevated from the floor at least 18 inch- es. While this may reduce the changes of flammable vapors
from a floor spill being ignited, gasoline and other flammable substancesshould never be store{] or used in the same room or
area containing a gas water heater or other open flame or spark producingappliance.
NOTE: Flammable vapors may be drawn by air currents from other areas of the structure to the appliance.
WARNING
HOTTER WATER CAN SCALD: Water heaters are intended to produce hot water. Water heated to a temperature which will satisfy clothes washing, dish washing, and other sanitizing needs can scald and permanently injure you upon contact. Some people are more likely to be permanently injured by hot water than others. These include the elderly, children, the infirm, or physlcally/mentaIly handicapped, if anyone using hot water in your home fits into one of these groups or if there is a local code or state law requiring a certain temperature water at the hot water tap, then you must take special precau-_ tions. In addition to usingthe lowest possible temperature set-' ting that satisfies your hot water needs, some type of temper- ing device, such as a mixing valve, should be used at the hot water taps used by these people or at the water heater. Mixing
valves are available at plumbing supply or hardware stores. Follow manufacturers instructions for i*nstallationof the valves.
Before changing the factory setting on the thermostat, read the "Temperature Regulation" section ;_nthis manual.
WARNING
BEFORE LIGHTING [PROPANE (L.P.) GAS WATER HEATERS]: Propane (LP.) gas is heavier than air. Should there be a leak in the system, the gas will settle near the ground. Basements, craw/spaces, skirted areas under mobile homes (even when ventilated), closets and areas below ground level will serve as pockets for the accumulation of this gas. Before attempting to light or relight the water heater'spilot or turning on a nearby electrical light switch, be absolutely sure there is no accumu- lated gas in the area. Search for odor of gas by sniffing at ground level in the vicinity of the appliance, tf odor is detect- ed, follow steps indicated at "For Your Safety" on the cover page of this manual then leave the premises.
WARNING
This water heater must not be installed directly on carpeting. Carpeting must be protected by a metal or wood panel beneath the appliance extending beyond the full width and depth of the appliance by at least 3 inches (76.2mm) in any_
direction,, or if the appliance is installed in an alcove or closet, the entire floor must be covered by the panel. Failure to heed this warning may result in a fire hazard.
