Prepare your log splitter for storage at the end of the season or if the log splitter will not be used for 30 days or more.
WARNING
WARNING: Never store the machine with fuel in the fuel tank inside of building where fumes may reach an open flame or spark or where ignition sources are present such as hot water and space heaters, furnaces, clothes dyers, stoves, electric motors, etc.
NOTE: A yearly
1.Clean the log splitter thoroughly.
2.Wipe the log splitter with an oiled rag to prevent rust, especially on the wedge and the beam.
Engine
IMPORTANT: It is important to prevent gum deposits from forming in the essential fuel system parts such as the carburetor, fuel filter, fuel hose or tank during storage. Also, alcohol blended fuels (called gasohol or using ethanol or methanol) can attract moisture which leads to separation and formation of acids during storage. Acidic gas can damage the fuel system of an engine while in storage.
1.Drain the fuel tank. Always drain the fuel into an approved container outdoors away from open flame. Be sure the engine is cool. Do not smoke while handling the fuel.
2.Start the engine and let it run until the fuel lines and carburetor are empty.
IMPORTANT: Never use engine or carburetor cleaner products in the fuel tank or permanent damage may occur. Use fresh fuel next season.
3.Remove the spark plug, pour approximately 1⁄2 oz. of engine oil into cylinder and crank it slowly to distribute the oil.
4.Replace the spark plug.
NOTE: Fuel stabilizer is an acceptable alternative in minimizing the formation of fuel gum deposits during storage.
Please follow the instructions below for storing your log splitter with fuel and stabilizer in the engine:
1.Add stabilizer to the gasoline in the fuel tank or storage container.
Always follow the mix ratio found on the stabilizer container.
2.Run the engine at least 10 minutes after adding stabilizer to allow the stabilizer to reach the carburetor.
IMPORTANT: Do not drain the gas tank and carburetor if using fuel stabilizer. Drain all the oil from the crankcase (this should be done after the engine has been operated and is still warm) and refill the crankcase with fresh oil.
Other•Do not store the gasoline from one season to another.
•Replace your gasoline can if it starts to rust.
•Store the log splitter in a clean, dry area. Do not store it next to any corrosive materials, such as fertilizer.
•Wipe the equipment with an oiled rag to prevent rust.
19