C E R T I F I E D
INDOOR OR OUTDOOR, GAS, DIRECT-FIRED, MAKEUP AIR/
HEATING SYSTEMS
(Specifications subject to change without notice.)
Operation/Maintenance/Service
Form
Applies to: | Model Series DV |
TABLE OF CONTENTS
Page | Page |
|
| Page | |||
MAINTENANCE |
| 8. Temperature Limit Safety Controls ... | 5 |
| •Manifold Arrangements | 8 | |
SECTION | •Manual Reset Limit Control | 5 |
| •Gas Pressure Switches | 8 | ||
Configuration | 2 | •Emergency Cut Off Limit Control .. | 6 | 12. | Outside Air Ambient Cutoff | 8 | |
9. Air Pressure Switches | 6 | ||||||
Maintenance Schedule | 2 | 13. | Door Switch | 9 | |||
•Low Air Flow Switch | 6 | ||||||
1A. Blower Bearings | 3 | 14. | Inlet Air Controls | 9 | |||
•High Air Flow Switch | 6 | ||||||
1B. Blower Belts | 3 |
| •Air Flow Dampers | 9 | |||
•Bypass Damper (Optional) Air |
|
| |||||
2. Filters | 3 |
|
| •Damper Motor | 9 | ||
Flow Switches | 6 |
| |||||
3. Manifold Gas Pressure | 3 |
| •Potentiometer | 9 | |||
10. Ignition System | 6 |
| |||||
4. Air Pressure | 4 |
| •Pressure Null Switch | 9 | |||
11. Gas Train Including |
|
| |||||
5. Circuit Indicator Board (check lights) 4 |
|
| •Photohelic Pressure Switch | 10 | |||
Burner, Gas Control Systems, |
|
| |||||
|
|
| 15. | Dirty Filter Switch | 10 | ||
6. Main Burner and Pilot Assembly | ...... 4 | Manifold Arrangements and Gas |
| ||||
OPERATION/SERVICE |
| Pressure Switches | 7 | 16. | Photoelectric Smoke Detector | 10 | |
| 7 | 17. | Firestat | 10 | |||
SECTION | |||||||
•Makeup Air Gas Control Systems .. | 7 | 18. | Freezestat | 10 | |||
|
| ||||||
Controls - Location | 5 | •Electronic Modulation Gas Control |
| 19. Troubleshooting | 11 | ||
7. Electronic Circuit Board with |
| Options AG30, AG31, AG32, |
|
| Chart 1 - General Troubleshooting | ||
| AG33, AG35, AG36 | 7 |
| Guide (Check the diagnostic lights on | |||
Diagnostic Lights | 5 |
| |||||
•Electronic Modulation Gas Control |
|
| the circuit board) |
| |||
|
|
|
|
| |||
|
| Option AG37 | 7 | Index | 12 |
References: Installation Manual, Form RZ 441
Replacement Parts Manual, Form RZ 741
FOR YOUR SAFETY
WARNING: The use and storage of gasoline or other flammable vapors and liquids in the vicinity of this appliance is hazardous.
If you smell gas:
1.Open windows.
2.Don't touch electrical switches.
3.Extinguish any open flame.
4.Immediately call your gas supplier.
WARNING: Improper installation, adjustment, alteration, service, or maintenance can cause property damage, injury or death. Read the installation, operation, and maintenance instructions thoroughly before installing or servicing this equipment.
KEEP THIS BOOKLET
FOR MAINTENANCE AND SERVICE REFERENCE.
Operating/Maintenance/Service Instructions
The information in this manual applies to Model Series DV, di-
If service is required, this system should be serviced only by a qualified service person. Service information in this booklet is intended as a guideline for a qualified
Mfg No. 161442 Page 1