Manuals / U-Line / Kitchen Appliance / Ice Maker

U-Line ADA15IM Harvest-2Cycle Figure, Water Fill Cycle Figure, Eject Cycle, Service and Repair

Models: ULN-SS1095 ADA15IM ULN-29R U-CO1175 BI-2115 ULN-95 U-CO29F ULN-98 U-CO29A U-1075WC U-1075BEV SP 18

1 66

Download 66 pages 37.32 Kb

Page 22

Harvest-2 Cycle (Figure 9)

Section 3 - Service and Repair

Harvest-2 Cycle (Figure 9)

•Ice maker ejector blades reach approximately 2:00 position and cam depresses the hold switch. Power goes through the hold switch to the ice maker motor and mold heater.

•Ejector blades stall on ice and ice maker motor pulsates until mold heater warms and ice releases.

					black
ON
OFF	black		black
SWITCH	black	FAN	black					ground
SWITCH		FAN
		MOTOR
		MOTOR
					brown			WATER
								WATER
								VALVE		white
		COMP.
		OVER
		START
black		LOAD		black
black		RELAY		black
				blue				HOLD	C
LIMIT								SWITCH
LIMIT
SWITCH						NC			NO
			WATER			yellow
						yellow
		C	FILL	NC		2
			SWITCH			2
			SWITCH			TEMP.
						TEMP.		red	NO	C
						CONTROL		red	NO	C
					3	CONTROL	1		BIN
									SWITCH
		black		ICE	orange
black				MAKER	orange


		orange		MOTOR
		orange
		black		MOLD HEATER	black
				MOLD HEATER						orange
										orange
										UL183-6
		Figure 9. Harvest-2 Cycle (Hold Switch in Switched Position)

Water Fill Cycle (Figure 10)

•Ice maker ejector blades reach approximately 10:00 position and cam depresses the water fill switch.

• Power to the water valve. Ice maker mold fills.

black

ON

OFF

black

black

SWITCH

FAN

ground

MOTOR

brown

WATER

VALVE

white

COMP.

OVER

START

black

LOAD

black

RELAY

blue

HOLD

C

SWITCH

LIMIT

SWITCH

NC

NO

WATER

yellow

C

FILL

NC

2

SWITCH

TEMP.

red

NO

C

CONTROL

3

1

BIN

SWITCH

black

ICE

orange

black

MAKER

orange

MOTOR

black

MOLD HEATER

black

orange

UL183-7

Figure 10. Water Fill Cycle

Eject Cycle

• Ejector blades push ice into bucket and stop at 12:00 position.

•Temperature control terminals 2 and 3 have closed during harvest cycle.

•Next freeze cycle begins with power to the compressor and condenser fan.

3-7

Image 22

U-Line ADA15IM, SP 18, U-1075BEV, U-1075WC Harvest-2Cycle Figure, Water Fill Cycle Figure, Eject Cycle, Service and Repair

Contents

ULN-SS1095Icemaker U-CO29F U-CO29A ULN-29R Entertain with U-LineEleganceSP ULN-95Icemaker ULN-98Icemaker U-1075BEV U-1075WC U-CO1175 BI-2115 ADA15IMINTRODUCTION POTENTIAL PROBLEMS WITH HFC-134ASection 1 - General Information SECTION 3 - SERVICE AND REPAIR TABLE OF CONTENTSSECTION 2 - TROUBLESHOOTING SECTION 5 - WIRING DIAGRAMSGeneral Precautions SAFETY PRECAUTIONSSafety Alert Definitions removal of power plug, or direct wiring can causeU-LINECORPORATION LIMITED WARRANTY Section 1 - General InformationSection 1 - General Information PRODUCT LIABILITY POLICYLeaders In Quality Undercounter Refrigeration PROOF OF PURCHASE WARRANTY CLAIMS PROCEDURESERIAL NUMBER FORMAT Section 1 - General InformationHow to Order Replacement Parts PARTS LISTINGSection 1 - General Information This page intentionally left blank Section 1 - General InformationSection 2 - Troubleshooting CUSTOMER CALL GUIDESystem REFRIGERATION SYSTEM DIAGNOSIS GUIDESection 2 - Troubleshooting SuctionINTERMITTENT ICE MAKER DIAGNOSIS FLOW CHARTSection 2 - Troubleshooting Low VoltageDANGER TROUBLESHOOTINGSection 2 - Troubleshooting CauseRemedy Section 2 - TroubleshootingCause Low ice productionFresh food temperature too cold Section 2 - TroubleshootingIce buildup in drain trough or drainage problem CauseREFRIGERATION SYSTEMS Section 3 - Service and RepairNormal Vapor/Compression Cycle Refrigeration COOLING MODE Section 3 - Service and RepairFrost Free Refrigeration DEFROST MODESection 3 - Service and Repair Air flow in at evaporator bladeSection 3 - Service and Repair COMPRESSOR/ELECTRICAL SPECIFICATIONSCompressor Pins EMI ERMODELS U-1075BEV, U-1075WC,29R- Figure Section 3 - Service and RepairCAPACITOR Figure 6. Electrical Relay and Overload ProtectorHarvest-1Cycle Figure ICE MAKER OPERATING CYCLESFreeze Cycle Figure Section 3 - Service and RepairEject Cycle Harvest-2Cycle FigureWater Fill Cycle Figure Section 3 - Service and RepairHarvest Cycle ICE MAKER OPERATING CYCLES U-CO29FMODELFreeze Cycle Water Fill CycleTEMPERATURE CONTROL SPECIFICATIONS Section 3 - Service and RepairFigure 12. Limit Switch LIMIT SWITCH SPECIFICATIONSSection 3 - Service and Repair 3-10Figure 13. Ice Maker Assembly REPLACING ICE MAKER ASSEMBLY CO29F ONLYSection 3 - Service and Repair 3-11THIS PAGE INTENTIONALLY LEFT BLANK Section 3 - Service and Repair3-12 110V P/N 220 VOLT CONVERSION LISTSection 4 - Parts 220V P/NU-LINEICE MAKER ASSEMBLY Section 4 - PartsModel U-LINEICE MAKER ASSEMBLYSection 4 - Parts Ice MakerMODEL SP18 Section 4 - PartsPart No. Black MODEL SP18Section 4 - Parts Part No. WhiteMODEL ULN-951 OF BI95B, BI95WH, BCM95Section 4 - Parts Section 4 - Parts MODEL ULN-951 OFBI95B, BI95WH, BCM95 ItemBI95BTP, WH95TP, SS95 MODEL ULN-952 OFSection 4 - Parts Section 4 - Parts MODEL ULN-952 OFBI95BTP, WH95TP, SS95 Part NoBI98B, BI98WH, SS98 MODEL ULN-98Section 4 - Parts Section 4 - Parts BI98B, BI98WH, SS98MODEL ULN-98 Part NoMODEL SS-1095 Section 4 - PartsDescription MODEL SS-1095Section 4 - Parts 4-13Model U-CO29F1 of MODEL U-CO29FSection 4 - Parts Part No. Black MODEL U-CO29F1 OFSection 4 - Parts Part No. WhiteMODEL U-CO29F2 OF Section 4 - PartsSection 4 - Parts MODEL U-CO29F2 OF4-17 3 1 MODEL U-CO29ASection 4 - Parts 11 7 4, 12U-CO29B-03 MODEL U-CO29ASection 4 - Parts U-CO29WH-03Section 4 - Parts MODEL ULN-29R1421 22 23 35 1 2 6 7 8 18 20 19 31 25 30 32 33Part No. Black MODEL 29RSection 4 - Parts Part No. WhiteMODEL 1075BEV Section 4 - PartsDescription MODEL 1075BEVSection 4 - Parts 4-23MODEL 1075WC Section 4 - PartsItem MODEL 1075WCSection 4 - Parts DescriptionSection 4 - Parts U-CO1175PAGE 1 OF4-26 Part No. Black U-CO1175PAGE 1 OFSection 4 - Parts DescriptionSection 4 - Parts U-CO1175PAGE 2 OF4-28 Part No. Black U-CO1175PAGE 2OFSection 4 - Parts DescriptionSection 4 - Parts MODEL BI-21154-30 Part No. Black MODEL BI-2115Section 4 - Parts Part No. White4-32 MODEL ADA15IMSection 4 - Parts 1X1XPart No. Black MODEL ADA15IMSection 4 - Parts DescriptionThis page intentionally left blank Section 4 - Parts4-34 CO29F - 115 VOLT Section 5 - Wiring DiagramsULN-95, ULN-98,SP18 & SS-1095- 115 VOLT COMBO 29FF WIRING DIAGRAMULN-29R- 115 VOLT U-CO29A,CO1175A, BI2115, ADA15IM - 115 VOLTSection 5 - Wiring Diagrams 1075BEV, 1075WC - 115 VOLT Section 5 - Wiring DiagramsCO-29A,CO1175, BI2115, ADA15IM - 220 VOLT ULN-95, ULN-98,SP18 & 22-1095- 220 VOLTSection 5 - Wiring Diagrams PRODUCT INFORMATION SERVICE ASSISTANCEFor Every Room There is a U-Line ABOUT U-LINE