MODEL | REPAIR |
RULES FOR SAFE INSTALLATION AND OPERATION
Read these rules and the instructions carefully.
SAFETY NOTICE: If this heater is not properly installed, a house fire may result. For your safety, follow the installation directions. Contact local building or fire officials about restrictions and installation inspection requirements in your area.
2 | 3 |
| 8 |
| 7 |
5 |
|
4 |
|
6 |
|
33 |
|
1
9 |
|
32 |
|
| 27 |
30 | 31 |
29 | 25 |
34 | 28 |
|
|
|
| 19 | 2827 - INTERIOR | PARTS AUTOMATIC COAL BURNING |
|
|
|
| 12 | 15 | CIRCULATOR |
21 | 13 | 10 | 16 | 18 |
| HEATER |
11 | 35 | 14 | ||||
|
|
| 17 |
|
|
|
|
| 26 | 20 |
|
|
|
24
22 | 23 |
1.Check local codes. The installation must comply with their rulings. Do not install this heater in a mobile home or trailer.
2.Always connect this heater to a chimney or vent to the outside. Never vent to another room or inside a building.
3.Do not connect a COAL burning heater to an aluminum Type B gas vent. This is not safe and is prohibited by all codes. This heater requires connection to approved chimneys: Either a factor built 6" UL 103HT or a lined and approved and recently in- spected and cleaned masonry chimney with a 6" flue, preferably round. A larger masonry flue may be used, so long as the
The chimney portion (whether
4.Be sure that your Chimney is safely con- structed and in good repair. Have the chim- ney inspected by the Fire Department or a qualified inspector (such as a Chimney sweep). Your insurance company may be able to recommend a qualified inspector.
5.Inspect chimney connector and chimney twice monthly during the heating season for any deposit of creosote or soot which must be removed.
Provide air for combustion from outside the
6.house into the room where the heater is located. If the intake is not in the same room, air must have free access to the room.
CAST IRON PARTS MUST BE "SEA-
7.SONED" TO AVOID CRACKING. BUILD ONLY SMALL FIRES ON FIRST USE. To prevent injury, do not allow anyone to
8.use this heater who is unfamiliar with the correct operation of the heater. Do not allow children to use or in any way operate this heater.
CAUTION: DO NOT TOUCH THE HEATER UNTIL IT HAS COOLED. ALWAYS WEAR GLOVES WHEN REFUELING THIS UNIT OR WORKING WITH METAL CABINET PARTS.
9. | For further information on using your |
| heater safely, obtain a copy of the National |
| Fire Protection Association (NFPA) pub- |
| lication "Using Coal and Wood Stoves |
| Safely" NFPA No. |
| dress of the NFPA is Battery March Park, |
| Quincy, MA. 02269. |
10. | Keep the ash pit section free of excess |
| ashes. Do not allow ashes to stack higher |
| than the sides of the ash pan. |
11. | DISPOSAL OF ASHES- Ashes should be |
| placed in a metal container with a tight |
| fitting lid. Keep the closed container on a |
| |
| well away from all combustible materials. |
| Keep the ashes in the closed container |
| until all cinders have thoroughly cooled. |
| The ashes may be buried in the ground or |
| picked up by a refuse collector. |
12. | CAUTION: The special paints used on |
| your heater may give off some smoke |
| while they are curing during first few fires. |
| Build small fires at first. The metals used |
| in construction of the heater has a light |
| coating of oil. This could give off smoke |
| and/or odors when heater is used for the |
| first couple of times. This should disap- |
| pear after a short period of time. Once this |
| |
13. cur. | |
| CARING FOR PAINTED PARTS- This |
| heater has a painted outside jacket, which |
| is durable but it will not stand rough han- |
| dling or abuse. When installing your heater, |
| use care in handling. Clean with soap and |
| warm water when heater is not hot. DO |
| NOT use any harsh chemicals (acids or |
| caustics) or scouring powder, as these |
14. wear and dull the finish. | |
| KEEP THE FEED DOOR, ASH DOOR |
| AND CABINET DOOR CLOSED AT ALL |
| TIMES EXCEPT WHILE TENDING THE |
| HEATER. DO NOT OVERFIRE THE |
| HEATER. THIS WILL HAPPEN IF THE |
| FEED DOOR, OR PARTICULARLY THE |
| ASH DOOR, IS LEFT OPEN DURING |
| OPERATION. UNDER EXTREME CON- |
| DITIONS THIS CAN PRODUCE DAN- |
| GEROUS RESULTS. AS A MINIMUM, IT |
15. | WILL ALLOW THE PAINT TO DIS- |
| COLOR. |
| Use coal only. DO NOT USE the coal |
| bricks that are manufactured from coal |
18
3
dust and a |