Annual Service Check List
The procedures and information on pages 7 through 11 are intended only for a qualified service technician who has the necessary equipment to inspect and adjust boiler and burner. A homeowner should never attempt these procedures. Qualified service technician must read pages 2 and 3 before proceeding.
|
|
|
| D | D | D | D | D | D | D | D | D | D |
|
|
|
|
| A | A | A | A | A | A | A | A | A | A |
|
|
| Annual Service Call Check List | T | T | T | T | T | T | T | T | T | T |
| |
|
| (follow in order listed below) | E | E | E | E | E | E | E | E | E | E | Comments | |
|
|
|
|
|
|
|
|
|
|
|
|
| ||
1 | Check that boiler area is free from |
|
|
|
|
|
|
|
|
|
|
| ||
| combustible materials, gasoline and other |
|
|
|
|
|
|
|
|
|
|
| ||
| flammable vapors and liquids. |
|
|
|
|
|
|
|
|
|
|
| ||
|
|
|
|
|
|
|
|
|
|
|
|
| ||
2 | Check for and remove any obstruction to |
|
|
|
|
|
|
|
|
|
|
| ||
| combustion and ventilation air flow to boiler. |
|
|
|
|
|
|
|
|
|
|
| ||
|
|
|
|
|
|
|
|
|
|
|
|
| ||
3 | Check breeching and chimney or vent for |
|
|
|
|
|
|
|
|
|
|
| ||
| obstructions, damage, etc. Repair or replace |
|
|
|
|
|
|
|
|
|
|
| ||
| as necessary. |
|
|
|
|
|
|
|
|
|
|
| ||
|
|
|
|
|
|
|
|
|
|
|
|
| ||
4 | Clean boiler flueways. See page 9. |
|
|
|
|
|
|
|
|
|
|
| ||
|
|
|
|
|
|
|
|
|
|
|
|
| ||
5 | Perform service on relief valve and circulator. |
|
|
|
|
|
|
|
|
|
|
| ||
| See page 11. |
|
|
|
|
|
|
|
|
|
|
| ||
|
|
|
|
|
|
|
|
|
|
|
|
| ||
6 | Check boiler and piping for leaks and repair if |
|
|
|
|
|
|
|
|
|
|
| ||
| found. Check for leaks at tankless heater |
|
|
|
|
|
|
|
|
|
|
| ||
| plate. Tighten nuts only if leaks are found (for |
|
|
|
|
|
|
|
|
|
|
| ||
| WTGO torque to |
|
|
|
|
|
|
|
|
|
|
| ||
|
|
|
|
|
|
|
|
|
|
|
|
| ||
7 | Inspect and adjust burner. See burner manual |
|
|
|
|
|
|
|
|
|
|
| ||
| and: |
|
|
|
|
|
|
|
|
|
|
|
| |
| - | change | nozzle. |
|
|
|
|
|
|
|
|
|
|
|
| - | check | ignition electrode settings. |
|
|
|
|
|
|
|
|
|
|
|
| - clean blower housing and wheel. |
|
|
|
|
|
|
|
|
|
|
| ||
| - | make sure blower wheel turns freely. |
|
|
|
|
|
|
|
|
|
|
| |
| - | oil burner motor if required. |
|
|
|
|
|
|
|
|
|
|
| |
| - | clean air inlet. |
|
|
|
|
|
|
|
|
|
|
| |
| - clean or change fuel filter and strainer. |
|
|
|
|
|
|
|
|
|
|
| ||
|
|
|
|
|
|
|
|
|
|
|
|
| ||
8 | Make sure boiler is filled with water. |
|
|
|
|
|
|
|
|
|
|
| ||
|
|
|
|
|
|
|
|
|
|
|
|
| ||
9 | Start unit and verify combustion settings with |
|
|
|
|
|
|
|
|
|
|
| ||
| combustion test equipment. |
|
|
|
|
|
|
|
|
|
|
| ||
| See page 10. |
|
|
|
|
|
|
|
|
|
|
| ||
|
|
|
|
|
|
|
|
|
|
|
|
| ||
10 | Verify operation of all controls on boiler. See |
|
|
|
|
|
|
|
|
|
|
| ||
| page 11. |
|
|
|
|
|
|
|
|
|
|
|
| |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
8
Any parts of the boiler furnished by