Poulan 418774, 96042006900, PB22H46YTX manual Points Troubleshooting

Page 35

26

.engine stopping before position (fast)

 

.engine stopping before position (fast) speed full

 

“OFF” engine turning

speed full and half between control throttle Move

.1

and half between set not control throttle Engine

.1

when “backfires” Engine

 

 

 

 

 

 

 

.servicing or

 

 

.transmission Purge

.3

shipment during transmission in trapped Air

.3

 

.belt drive motion Replace

.2

.broken or damaged, worn, belt drive Motion

.2

 

.position “engaged” in control freewheel Place

.1

.position “disengaged” in control Freewheel

.1

drive of Loss

 

 

 

 

 

.alternator Replace

.4

.alternator Faulty

.4

 

.regulator Replace

.3

.equipped) so (if regulator Faulty

.3

 

.connections all Check/clean

.2

.connections cable Poor

.2

 

.battery Replace

.1

.cell(s) battery Bad

.1

charge not will Battery

 

 

 

 

 

.fuse Replace

.5

.fuse Blown

.5

 

.connections and wiring Check

.4

.wiring damaged or Loose

.4

 

.switch light Check/replace

.3

.switch light Faulty

.3

 

.lamp(s) or bulb(s) Replace

.2

.out burned lamp(s) or Bulb(s)

.2

equipped) so (if

.“ON” switch light Turn

.1

.“OFF” is switch Light

.1

working not Headlight(s)

 

 

 

 

 

 

 

.mandrels around trash and leaves, grass,

 

 

.holes vent open to mandrels around Clean

.11

of buildup from holes vent deck mower Clogged

.11

 

.manual this in listed blades with Replace

.10

.used blades Improper

.10

 

.down edge sharp blades Reinstall

.9

.installed improperly Blades

.9

 

.belt drive mower Replace

.8

.worn belt drive Mower

.8

 

.housing mower of underside Clean

.7

.mower under trash and leaves grass, of Buildup

.7

 

.bolt blade Tighten .blade Replace

.6

.blade loose or bent Worn,

.6

 

.pressure air proper for tires Check

.5

.pressure air tire Low/uneven

.5

 

.deck mower Level

.4

.level not deck Mower

.4

 

.mowing before dry to grass Allow

.3

.grass Wet

.3

 

.speed slower to Shift

.2

.fast too speed Travel

.2

 

.position “FAST” in control throttle Place

.1

.slow too speed Engine

.1

discharge grass Poor

 

 

 

 

 

.mandrel blade Replace

.4

.mandrel blade Frozen

.4

 

.pulley idler Replace

.3

.pulley idler Frozen

.3

 

.belt drive mower Replace

.2

.belt drive mower Worn/damaged

.2

rotate

.obstruction Remove

.1

.mechanism clutch in Obstruction

.1

not will blades Mower

 

 

 

 

 

 

 

.mandrels around trash and leaves, grass,

 

 

.holes vent open to mandrels around Clean

.5

of buildup from holes vent deck mower Clogged

.5

 

.mandrel blade Replace

.4

.mandrel blade Bent

.4

 

.housing mower of underside Clean

.3

.mower under trash and leaves, grass, of Buildup

.3

 

.deck mower Level

.2

.level not deck Mower

.2

 

.bolt blade Tighten .blade Replace

.1

.blade loose or bent Worn,

.1

uneven - cut Poor

 

 

 

 

 

 

 

 

 

engaged

.department

 

 

 

clutch attachment with

center/ service authorized an contact corrected,

 

 

 

seat leaves operator when

not If .connections and switches wiring, Check

.1

.system control presence safety-operator Faulty

.1

run to continues Engine

 

 

 

 

 

 

 

.engaged is

 

 

.section Operation See

 

attachment other or mower

 

reverse into

.position "ON" ROS

 

while "ON" not is (ROS)

 

shifted is tractor

to key ignition Turn

.1

system operation Reverse

.1

when dies Engine

CORRECTION

CAUSE

PROBLEM

POINTS TROUBLESHOOTING

Page 34 Page 36
Image 35
Page 34 Page 36
Contents PB22H46YTX II. Slope Operation Safety RulesSafe Operation Practices for Ride-On Mowers General OperationIV. Towing ServiceIII. Children Table of Contents Unpack Carton AssemblyUnassembled Parts To Remove Tractor from CartonCheck Brake System Check Tire PressureCheck Deck Levelness Check for Proper Position of ALL BeltsOperation Reverse Operation System ROS on Position Know Your TractorHOW to USE Your Tractor To Operate Mower To Adjust Mower Cutting Height See FigTo Adjust Gauge Wheels See Fig System CharacteristicsTo Operate on Hills Service REMINDER/HOUR MeterBefore Starting the Engine Reverse Operation System ROSAutomatic Transmission Warm UP ADD GasolineTo Start Engine See Fig Purge TransmissionMowing Tips Lubrication Chart MaintenanceTires BatteryTractor Brake OperationEngine Spark Plugs CleaningEngine OIL Filter MufflerTo Remove Mower See Fig Service and AdjustmentsTo Install Mower See Fig Install belt on engine pulley M, in belt keepers G To Level Mower To Check Brake To Check and Adjust Brake See FigTo Adjust Brake To Replace Mower Drive BeltTo Remove Wheel for Repairs See Fig To Start Engine with a Weak Battery See FigTo Replace Motion Drive Belt See Fig Front Wheel TOE-IN/CAMBERTo Replace Headlight Bulb To Adjust Throttle Control CableTo Adjust Choke Control To Adjust CarburetorEngine OIL StorageOther Fuel SystemTroubleshooting Points Engine dies when Limited Warranty Service Notes Fold Along This Dotted Line Degree Slope Only Ride UP and Down Hill Not Across Hill Degrees MAXParts and Service Service and Parts Suggested Guide for Sighting Slopes for Safe Operation Page Warranty Limited Points Troubleshooting Fuel in Water OIL Engine OtherTractor Trolcon Choke Justad to Adjustments and ServiceCarburetor Adjust to Assembly Grill and Hood Remove toBelt Drive Motion Replace to Fig See Battery Weak a with Engine Start toRepairs for Wheel Remove to BERIN/CAM-TOE Wheel Front26 .FIG Brake Adjust and Check toBelt Drive Mower Replace to 27 .FIG23 .FIG Mower Level to25 .FIG 24 .FIG20 .FIG 21 .FIG 19 .FIGGrooves Pulley Mower ALL Routing Proper for Belt Check Important17 .FIG Fig See Mower Install toFig See Mower Remove to Muffler CleaningFig See Filter Fuel LINE-IN Plugs SparkCooling Transaxle Filter AIROperation Brake Fig See Removal BladeCare Blade TiresUSE Each Before MaintenanceRecommendations General Schedule12 .FIG Tips MowingUP Warm Transmission Automatic Transmission PurgeFig See Engine Start to Gasoline ADD3 .Figs See Transport to Meter REMINDER/HOUR ServiceEngine the Starting Before Level OIL Engine CheckMower Operate to Fig See Wheels Gauge Adjust toHeight Tingcut Mower Adjust to Characteristics SystemBackward and Forward Move to Tortrac Your USE to HOWOperation Only Models Automatic Wheel Free Op See Skid OFF Tortrac Drive to ALL of Position Proper for CheckTrolscon Function and location for section tionaerOp See Skid OFF Tractor Roll to Fig See Seat AdjustParts Unassembled Toncar from Tractor Remove toContents of Table Children Rules SafetyMowers On-Ride for TowingMowers On-Ride for Practices Operation Safe Operation SlopeOperation General Tractor Lawn PB22H46YTX Model Manual Operators

418774, PB22H46YTX, 96042006900 specifications

The Poulan 418774, also known by its model number 96042006900, is a robust and versatile lawn tractor that caters to homeowners and lawn care enthusiasts alike. Designed for residential use, the PB22H46YTX offers a host of features that enhance its performance, comfort, and efficiency, making it an excellent option for maintaining medium to large-sized lawns.

One of the standout characteristics of the Poulan PB22H46YTX is its powerful 22-horsepower Briggs & Stratton engine. This reliable engine provides ample power to tackle various terrain types and allows for effective mowing, even in challenging conditions. One of the engine's key features is its overhead valve design, which promotes better fuel efficiency and reduces emissions, aligning with modern environmental standards.

The PB22H46YTX comes equipped with a 46-inch cutting deck, which is ideal for larger mowing areas. This wide cutting swath allows users to cover more ground in less time, significantly reducing the time spent on yard maintenance. The cutting deck also features an adjustable height range, giving users the flexibility to choose the optimal grass length for their specific lawn care needs.

Another significant feature of the Poulan PB22H46YTX is its hydrostatic transmission. This technology allows for seamless speed adjustments, offering a smoother driving experience without the need for gear shifting. Users can easily maneuver the tractor across the yard, making it easier to navigate around trees, flower beds, and other obstacles.

In terms of comfort, the PB22H46YTX includes a spacious operator's seat with ergonomic design, ensuring optimal support during extended periods of use. The dashboard is user-friendly, providing easy access to essential controls and information, including engine status and speed.

Durability is another hallmark of the Poulan brand, and the PB22H46YTX is built to last. It features a reinforced steel frame and heavy-duty tires, providing stability and traction on various surfaces. Additionally, the cutting blades are designed for longevity and can handle tough grass conditions with ease.

Overall, the Poulan 418774, 96042006900, and PB22H46YTX model offers an ideal blend of power, comfort, and advanced features, making it a top choice for anyone looking to maintain their lawn effortlessly and efficiently.
Top Page Image Contents