Poulan 188781 owner manual Table Of Contents, Product Specifications, Customer Responsibilities

Page 4
PRODUCT SPECIFICATIONS

PRODUCT SPECIFICATIONS

GASOLINE CAPACITY

4.0 GALLONS

AND TYPE:

UNLEADED REGULAR

 

 

OIL TYPE (API-SF-SJ):

SAE 30 (above 32°F)

 

SAE 5W-30 (below 32°F)

OIL CAPACITY:

W/FILTER

4.0 PINTS

 

W/O FILTER 3.75 PINTS

 

 

SPARK PLUG:

CHAMPION QC12YC

(GAP: .040")

 

 

 

 

 

GROUND SPEED (MPH):

Forward:

0-5.5

 

Reverse

0-2.4

 

 

 

TIRE PRESSURE:

FRONT:

14 PSI

 

REAR:

10 PSI

 

 

CHARGING SYSTEM:

3 AMPS BATTERY

 

5 AMPS HEADLIGHTS

 

 

 

BATTERY:

AMP/HR:

35

 

MIN. CCA:

280

 

CASE SIZE:

U1R

 

 

BLADE BOLT TORQUE:

27–35 FT. LBS.

 

 

 

CONGRATULATIONS on your purchase of a new tractor. It has been designed, engineered and manufactured to give you the best possible dependability and performance.

Should you experience any problem you cannot easily rem- edy, please contact your nearest authorized service center/ department. We have competent, well-trained technicians and the proper tools to service or repair this tractor.

Please read and retain this manual. The instructions will enable you to assemble and maintain your tractor properly. Always observe the “SAFETY RULES”.

CUSTOMER RESPONSIBILITIES

•Read and observe the safety rules.

•Follow a regular schedule in maintaining, caring for and using your tractor.

•Follow the instructions under “Maintenance” and “Stor- age” sections of this owner’s manual.

WARNING: This tractor is equipped with an internal com- bustion engine and should not be used on or near any unimproved forest-covered, brush-covered or grass-covered land unless the engine’s exhaust system is equipped with a spark arrester meeting applicable local or state laws (if any). If a spark arrester is used, it should be maintained in effective working order by the operator.

A spark arrester for the muffler is available through your nearest authorized service center/department (See REPAIR PARTS section of this manual).

In the state of California the above is required by law (Section 4442 of the California Public Resources Code). Other states may have similar laws. Federal laws apply on federal lands.

TABLE OF CONTENTS

SAFETY RULES

2-3

PRODUCT SPECIFICATIONS

4

CUSTOMER RESPONSIBILITIES

4

ASSEMBLY

6-8

OPERATION

9-15

MAINTENANCE SCHEDULE

16

MAINTENANCE

16-19

SERVICE AND ADJUSTMENTS

20-25

STORAGE

26

TROUBLESHOOTING

27-28

REPAIR PARTS - TRACTOR

30-45

WARRANTY

46

4

Page 3 Page 5
Image 4
Page 3 Page 5
Contents MODEL PD22H42STAIMPORTANT MANUAL LAWN TRACTORSAFETY RULES IV. SERVICESAFE OPERATION PRACTICES FOR RIDE-ON MOWERS I. GENERAL OPERATIONWARNING In order to prevent ac- cidental starting when setting up, transporting, adjusting or making re- pairs, always disconnect spark plug wire and place wire where it cannot contact spark plug PRODUCT SPECIFICATIONS TABLE OF CONTENTSCUSTOMER RESPONSIBILITIES UNASSEMBLED PARTS Steering WheelSeat SteeringASSEMBLY TOOLS REQUIRED FOR ASSEMBLYHOW TO SET UP YOUR TRACTOR CHECK BATTERY See FigINSTALL SEAT See Fig INSTALL MULCHER PLATE See Figs TO CONVERT TO BAGGING OR DISCHARGINGCHECK TIRE PRESSURE CHECK DECK LEVELNESSOPERATION KNOW YOUR TRACTOR HEIGHT ADJUSTMENT KNOB - Used to adjust the mower cutting heightHOW TO USE YOUR TRACTOR TO ADJUST MOWER CUTTING HEIGHT See FigTO SET PARKING BRAKE See Fig STOPPING See FigTO ADJUST GAUGE WHEELS See Fig TO OPERATE MOWER See FigTO OPERATE ON HILLS TO TRANSPORT See Figs. 5 andBEFORE STARTING THE ENGINE TOWING CARTS AND OTHER ATTACH- MENTSCHECK ENGINE OIL LEVEL ADD GASOLINEMOWING TIPS PURGE TRANSMISSIONMULCHING MOWING TIPS MAX 1/3MAINTENANCE LUBRICATION CHARTGENERAL RECOMMENDATIONS BEFORE EACH USEBATTERY TRACTORBRAKE OPERATION TIRESENGINE V-BELTSTRANSAXLE COOLING TRANSAXLE PUMP FLUIDCLEANING CLEAN AIR SCREENCLEAN AIR INTAKE/COOLING AREAS AIR FILTER See FigTO INSTALL MOWER See Fig SERVICE AND ADJUSTMENTSTO REMOVE MOWER See Fig TO LEVEL MOWER HOUSING BOTH FRONT LINKS MUST BE EQUAL IN LENGTHTO CHECK AND ADJUST BRAKE See Fig TO REPLACE MOWER BLADE DRIVE BELT See FigTO REPLACE MOTION DRIVE BELT See Fig WITH PARKING BRAKE “ENGAGED”TRANSMISSION REMOVAL/REPLACEMENT TRANSAXLE MOTION CONTROL LEVER NEUTRAL ADJUSTMENT See FigTO ADJUST STEERING WHEEL ALIGN- MENT FRONT WHEEL TOE-IN/CAMBERTO START ENGINE WITH A WEAK BATTERY See Fig REPLACING BATTERY See FigTO REPLACE HEADLIGHT BULB INTERLOCKS AND RELAYSTO REMOVE HOOD AND GRILL ASSEMBLY See Fig TO ADJUST THROTTLE CONTROL CABLE See FigTO ADJUST CHOKE CONTROL See Fig TO ADJUST CARBURETORSTORAGE OTHERFUEL SYSTEM ENGINE OILTROUBLESHOOTING POINTS Loss of powerWill not start Hard to startBattery will not charge Engine continues to runwith attachment clutch engagedSCHEMATIC TRACTOR - - MODEL NUMBER PD22H42STAELECTRICAL 2441144927 chassiselite svpro7 CHASSIS259 TRACTOR - - MODEL NUMBER PD22H42STA DRIVE drive-fender.stlt29TRACTOR - - MODEL NUMBER PD22H42STA STEERING ASSEMBLY steeringpl.lt47STEERING ASSEMBLY SEAT ASSEMBLY WHEELS AND TIRES DECALS25,8 4,10 ENGINE OPTIONAL EQUIPMENT Spark Arresterengine-bs intek-twin39 112TRACTOR - - MODEL NUMBER PD22H42STA MOWER DECK 42deckman-t-path4Mower Deck Assembly MOWER LIFT lift-rh.1pc.stlt10TRACTOR - - MODEL NUMBER PD22H42STA LIMITED WARRANTY SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION ONLY RIDE UP AND DOWN HILL NOT ACROSS HILL 15 DEGREES MAXPARTS AND SERVICE FOR SERVICE OR REPLACEMENT PARTS
Top Page Image Contents