TROUBLESHOOTING CHART:
| PROBLEM | CAUSE | CORRECTION | ||
| Will not start | 1. | Out of fuel. | 1. | Fill fuel tank. |
|
| 2. | Engine not “CHOKED” | 2. | See “TO START ENGINE” in |
|
|
| properly. |
| Operation section. |
|
| 3. | Engine flooded. | 3. | Wait several minutes before |
|
|
|
|
| attempting to start. |
|
| 4. | Bad spark plug. | 4. | Replace spark plug. |
|
| 5. | Dirty air filter. | 5. | Clean/replace air filter. |
|
| 6. | Dirty fuel filter. | 6. | Replace fuel filter. |
|
| 7. | Water in fuel. | 7. | Empty fuel tank and carbure- |
|
|
|
|
| tor, refill tank with fresh gas- |
|
|
|
|
| oline and replace fuel filter. |
|
| 8. | Loose or damaged wiring. | 8. | Check all wiring. |
|
| 9. | Carburetor out of adjustment. | 9. | See “To Adjust Carburetor” |
|
|
|
|
| in Service and Adjustments |
|
|
|
|
| section. |
|
| 10. Engine valves out of | 10. Contact an authorized | ||
|
|
| adjustment. |
| service center/department. |
|
|
|
|
| |
Hard to start | 1. | Dirty air filter. | 1. | Clean/replace air filter. | |
|
| 2. | Bad spark plug. | 2. | Replace spark plug. |
|
| 3. | Weak or dead battery. | 3. | Recharge or replace battery. |
|
| 4. | Dirty fuel filter. | 4. | Replace fuel filter. |
|
| 5. | Stale or dirty fuel. | 5. | Empty fuel tank and refill tank |
|
|
|
|
| with fresh, clean gasoline. |
|
| 6. | Loose or damaged wiring. | 6. | Check all wiring. |
7.Carburetor out of adjustment. 7. See “To Adjust Carburetor” in Service and Adjustments section.
| 8. | Engine valves out of | 8. | Contact an authorized |
|
| adjustment. |
| service center/department. |
|
|
|
|
|
Engine will not | 1. | Brake pedal not depressed. | 1. | Depress brake pedal. |
turn over | 2. | Attachment clutch is engaged. | 2. | Disengage attachment clutch. |
| 3. | Weak or dead battery. | 3. | Recharge or replace battery. |
| 4. | Blown fuse. | 4. | Replace fuse. |
| 5. | Corroded battery terminals. | 5. | Clean battery terminals. |
| 6. | Loose or damaged wiring. | 6. | Check all wiring. |
| 7. | Faulty ignition switch. | 7. | Check/replace ignition switch. |
| 8. | Faulty solenoid or starter. | 8. | Check/replace solenoid or |
|
|
|
| starter. |
| 9. | Faulty operator presence | 9. | Contact an authorized |
|
| switch(es). |
| service center/department. |
|
|
|
|
|
Engine clicks but | 1. | Weak or dead battery. | 1. | Recharge or replace battery. |
will not start | 2. | Corroded battery terminals. | 2. | Clean battery terminals. |
| 3. | Loose or damaged wiring. | 3. | Check all wiring. |
| 4. | Faulty solenoid or starter. | 4. | Check/replace solenoid or |
|
|
|
| starter. |
|
|
|
|
|
Loss of power | 1. | Cutting too much grass/too | 1. | Raise cutting height/reduce |
|
| fast. |
| speed. |
| 2. | Throttle in “CHOKE” position. 2. Adjust throttle control. | ||
| 3. | 3. | Clean underside of mower | |
|
| trash under mower. |
| housing. |
| 4. | Dirty air filter. | 4. | Clean/replace air filter. |
| 5. | Low oil level/dirty oil. | 5. | Check oil level/change oil. |
32