RedMax GZ3500T manual Fuel and Chain Oil, Gasoline Requirements, OIL Requirements

Page 9

GZ3500T

6. Fuel and Chain Oil

FUEL

WARNING

•Gasoline is very flammable. Avoid smoking or bringing any flame or sparks near fuel. Make sure to stop the engine and allow it cool before refuel- ing the unit. Select outdoor bare ground for fuel- ing and move at least 10 ft (3 m) away from the fueling point before starting the engine.

■GASOLINE REQUIREMENTS

• All 2-Stroke RedMax Products are powered by Zenoah Professional-Commercial Duty, Hi-Performance, Hi- RPM, Air Cooled 2-Stroke engines.

RedMax/Zenoah – Hi-Performance 2-stroke engines produce higher HP outputs as compared to standard Home Owner Duty or Light Commercial Duty produc- tion engines offered by most manufacturers.

• Exhaust emission are controlled by the fundamental engine parameters and components (eq . , carburation, ignition timing and port timing) without addition of any major hardware or the introduction of an inert material during combustion.

• The RedMax/Zenoah Engines are registered and cer- tified with CARB (California Air Resources Board) and EPA (Environmental Protection Agency) to operate on CLEAN Mid-grade 89 octane or Premium, unleaded (lead-free) gasoline and RedMax Air-Cooled "Max Life", Synthetic blend Premium two-stroke engine oil mixed at 50:1 ratio.

• Unleaded gasoline is recommended to reduce the contamination of the air for the sake of your health and the environment.

• This Hi-Performance Air Cooled 2-stroke Engine re-

quires the use of Minimum 89 Octane [R+M] (Mid 2

grade or Premium) clean gasoline.

Gasoline may contain maximum of 10% Ethanol (grain alcohol) or up to 15% MTBE (Methyl tertiary-butyl ether). Gasoline containing Methanol (Wood Alcohol) is NOT approved.

NOTE

•IF octane rating of the Mid Grade gasoline in your area is lower than 89 Octane use Premium Unleaded Gasoline. The majority of all 2-stroke engine manu- facturers in the USA and Canada recommend using gasoline with 89 Octane or higher.

WARNING

•Gasoline with an octane rating lower than 89 will greatly increase the engines operating temperature. Low octane gasoline will cause detonation (knock) resulting in piston seizures and major internal engine components damage.

•Poor quality gasolines or oils may damage sealing rings, fuel lines or fuel tank of the engine.

NOTE

•Failures caused by operating engines on gasoline with octane rating lower than 89 are not covered by the RedMax Two-Stroke engine warranty.

WARNING

•Alternative Fuels (Not Gasoline) Alternative fuels, such as E-15 (15% ethanol), E- 20 (20% ethanol), E-85 (85% ethanol) are NOT clas- sified as gasoline and are NOT approved for use in RedMax 2-stroke gasoline engines. Use of al- ternative fuels will cause major engine perfor- mance and durability problems such as: improper clutch engagements, overheating, vapor lock, power loss, lubrication deficiency, deterioration of fuel lines, gaskets and internal carburetor com- ponents, etc... Alternative fuels cause high mois- ture absorption into the fuel/oil mixture leading to oil and fuel separation.

■OIL REQUIREMENTS

•Use only RedMax "Max Life", Synthetic blend Pre- mium Air- Cooled two-stroke engine oil or oil certified to ISO-L-EGD (ISO/CD1378) standard AND one that is JASO-FD registered. RedMax Air-Cooled "Max Life", Synthetic blend Premium two stroke engine oil and ISO-L-EGD (ISO/CD1378) AND JASO-FD oils are fully compatible with gasoline's containing 10% Etha- nol. RedMax Air-Cooled "Max Life", Synthetic blend Premium two stroke engine oil and ISO-L-EGD (ISO/ CD1378) AND JASO-FD oils are Universal and should be mixed at 50:1 ratio for all 2 stroke air cooled engines sold in the past regardless of mixing ratios specified in those manuals.

•If the oil is registered with JASO, the JASO Logo with FD and registration number will be displayed on the container. The highest JASO rating is "FD", which equals the ISO-L-EGD rating. Lower ratings are "FC", "FB", and "FA".

U

S

US-9

Page 8 Page 10
Image 9
Page 8 Page 10
Contents GZ3500T Contents Specifications GZ3500T Power unitParts location Because of high temperature Basic Safety RulesFor safe operation US-4Before USE Fuel SafetyCutting TransportDisposal Kickback Safety Precautions For Chain SAW UsersEmission Control Symbols on the MachineAn emission control label is located on the engine US-7Installing Guide Bar and Saw Chain Standard saw unit package contains the items as illustratedPay attention to the correct direction of the saw chain Fuel Fuel and Chain OilGasoline Requirements OIL RequirementsHOW to MIX Fuel Recommended Mixing Ratio Gasoline 50 OIL Redmax TWO-STROKE Engine WarrantyFueling the Unit For Your Engine LIFE, AvoidOperating the Engine Adjusting the CarburetorStarting the Engine Normal start Turn the choke knob to the closed positionChain Brake SawingReleasing the Brake Stopping the EngineFelling a Tree Maintenance Maintenance After Each USEPeriodical Service Points Maintenance of Saw Chain and Guide Bar Saw ChainUS-15 Case 2. Lack of power/Poor acceleration/ Rough idling Troubleshooting GuideDisposal Case 1. Starting failureUS-17 Manufacturer’s warranty coverageUS-18 Limited Warranty

GZ3500T specifications

The RedMax GZ3500T is a robust and versatile power equipment solution designed for professional landscapers and avid gardening enthusiasts alike. This high-performance tool stands out with its innovative features, powerful engine, and user-friendly design.

At the heart of the GZ3500T is a powerful 35cc 2-stroke engine, delivering impressive power and efficiency to handle a variety of tasks. This engine is designed to provide maximum torque and consistent performance, making it ideal for tackling thick grass and heavy brush with ease. The incorporation of RedMax's advanced Smart Start technology ensures that starting the engine is effortless, reducing pull resistance for easy ignition.

One of the standout features of the GZ3500T is its high-quality cutting system. The trimmer is equipped with a professional-grade double-line cutting head, allowing for swift cutting action and a clean finish. The cutting width of the GZ3500T is optimal for both narrow and wide spaces, making it suitable for both precise trimming and larger areas. The auto-feed head simplifies the process of line replacement, ensuring that users can quickly get back to their work without tedious interruptions.

User comfort and ergonomics are paramount in the design of the GZ3500T. Its lightweight construction, combined with a well-balanced design, minimizes fatigue during prolonged use. The adjustable handlebars offer customization for users of different heights, enhancing control and maneuverability. Additionally, the unit features a padded harness system that distributes weight evenly across the shoulders, further increasing comfort during operation.

Durability is another key characteristic of the RedMax GZ3500T. Built with high-quality materials and components, this trimmer is designed to withstand the rigors of professional use. The fuel tank is built for efficiency, allowing for longer run times between refueling. Furthermore, the engine is engineered to reduce emissions, complying with environmental regulations while providing a cleaner operation.

In summary, the RedMax GZ3500T is a top-tier trimmer that combines power, efficiency, and comfort. With its cutting-edge technologies, user-centric design, and durability, it serves as an essential tool for anyone looking to achieve a pristine landscape. Whether used for commercial purposes or personal projects, the GZ3500T proves to be an indispensable ally in the field.
Top Page Image Contents