Simplicity 5022285, CE Models instruction sheet General Operating Safety, Checks Before Starting

Page 16

Operation

GENERAL OPERATING SAFETY

Before first time operation:

•Be sure to read all information in the Safety and Operation sections before attempting to operate this tractor and mower.

•Become familiar with all of the controls and how to stop the unit.

•Drive in an open area without mowing to become accustomed to the unit.

CHECKS BEFORE STARTING

•Check that crankcase is filled to full mark on dipstick. See the engine Operator’s Manual for instructions and oil recommendations.

•Make sure all nuts, bolts, screws and pins are in place and tight.

•Adjust the seat position, and make certain you can reach all controls from operator’s position.

•Fill the fuel tank with fresh fuel. Refer to engine manual for fuel recommendations.

WARNING

Never operate on slopes greater than 17.6 percent (10°) which is a rise of 3-1/2 feet (106 cm) vertically in 20 feet (607 cm) horizontally.

Select slow ground speed before driving onto a slope. Use extra caution when operating on slopes with a rear-mounted grass catcher.

Mow across the face of slopes, not up and down, use caution when changing directions and

DO NOT START OR STOP ON SLOPE.

WARNING

Never allow passengers to ride on the unit.

Before leaving the operator’s position for any reason, engage the parking brake, disengage the PTO, stop the engine and remove the key.

To reduce fire hazard, keep the engine, tractor and mower free of grass, leaves and excess grease. Do not stop or park tractor over dry leaves, grass or combustible materials.

Gasoline is highly flammable and must be handled with care. Never fill the tank when the engine is still hot from recent operation. Do not allow open flame, smoking or matches in the area. Avoid over-filling and wipe up any spills.

WARNING

Do not load this zero-turn rider on a trailer or truck using two separate ramps. Only use a single ramp that is at least one foot wider than the width of the rear wheels of this rider. This rider has a zero turning radius and the rear wheels could fall off the ramps, or the rider could tip over injuring the operator or bystanders.

12

Page 15 Page 17
Image 16
Page 15 Page 17
Contents Operator’s Manuals Paper SizePress BinderyPage 21HP Zero-Turn Riders 23HP Zero-Turn RidersPage Table of Contents General Operation Safety Rules and InformationTransporting and Storage Slope Operation ChildrenEmissions Towed Equipment RIDE-ON UnitsService & Maintenance Service and MaintenanceSafe Handling of Gasoline Safety Rules & Information Roll BAR InstructionsInspection and Maintenance of the Roll BAR Seat Belt Identification Numbers CE Identification TAG MarkingsNorth American CE ModelsSafety Decals Safety DecalsDecal Danger, Mower Decal MainPart No Decal Warning Part NoSafety Interlock System Safety Icons & Interlock SystemOperational Safety Checks PTO Power Take Off Switch Control FunctionsParking Brake ChokeFeatures & Controls General Operating Safety Checks Before StartingOperation Starting the EngineStopping the Rider MowingZero Turn Driving Practice Smooth TravelForward Travel Practice Reverse Travel PracticeExecuting an End-Of-Row Zero Turn Practice Turning Around a Corner Practice Turning In PlaceExecuting Turns Raise & Lower the Roll BAR To lower the roll barTo raise the roll bar Keep roll bar in the raised position and use seat beltAttaching a Trailer StorageSafety Items Rider MaintenanceEngine Maintenance Before Every Spring Each 100 250 Fall Use HoursRegular Maintenance Grease LubricationOil Battery Maintenance Cleaning the Battery and CablesCheck Hydraulic OIL Level Change Hydraulic OIL FilterServicing the Mower Blades Removing the BladeTroubleshooting Adjustments & Service Troubleshooting the RiderTroubleshooting, Adjustment & Service Troubleshooting the MowerGround Speed Control Lever Adjustment Seat AdjustmentSpeed Balancing Adjustment Parking Brake Adjustment Battery ChargingTo adjust the spring pre-load Rear Suspension AdjustmentTo adjust the upper mounting position PTO Clutch Adjustment Blade Brake CheckNeutral Adjustment RETURN-TO-NEUTRAL AdjustmentAdjustment Foot Pedal Adjustment Mowing Height AdjustmentTo adjust pedal position Deck Leveling Adjustment 4 SpacersHydraulic Pump Drive Belt Replacement Mower Belt Replacement Mower PTO Belt Idler Arm Stationary Idler PulleyDimensions EngineChassis Transmissions
Top Page Image Contents