Snapper 2690628 Check Mower Deck Gear Box Oil, Safety Interlock System Check, Blade Brake Check

Page 31

RegWP Maiflteflaflce

Check Mower Deck Gear Box Oil

Service Interval: Every Fall & Spring

To check the mower deck gear box oil:

1.Place a shop towel under the side opening to keep oil off the belt and pulleys.

2.Remove the side level plug (B, Figure 31) of the gear box. Oil should come out of the side hole. If not add SAE 85W-90 oil through the top fill hole (A) until oil comes out the side fill hole.

3.Replace the plugs and wipe up any spilled oil.

Safety Interlock System Check

Service Interval: Every Fall & Spring

Check the function of the safety interlock system using the test procedure found on page 9 of this manual. If the tractor fails any of the tests, see your dealer.

Blade Brake Check

Service interval: Every 100 Hours or Fall & Spring The mower should come to a complete stop within five seconds after PTO switch is turned off.

1.With tractor in neutral, PTO disengaged and operator in seat, start the engine. Make sure the area is clear of bystanders.

2.Engage the PTO and wait several seconds. Disengage the PTO and check the amount of time it takes for the mower to stop.

3.If the mower does not stop within five seconds, see your dealer.

Figure 28. Gear Box Fill Plug Location

A.Top Fill Plug

B.Side Level Plug

3O

Image 31

Contents 27HP Hydro Tractors & Mower Decks 54 Mower Decks GT600 SeriesAbleof Contents OporatingSafety Meving SafetyRuJes& lflfomatJofl SafetyRulesandinformation Service & Maintenance Service and MaintenanceTracto Mower ID Tag JdefltificatioflNumbersDecal =Attachment Lift Control Decal Cutting Safety DecalsDecal =Throttle Decal Transmission PositionsPurpose of the safety interlock system Safetylcofls/ SafetyinteplockTestSafety icons Operational Safety ChecksChoke Select lVlodels Control FunctionsFront A×Je Oil LeveJ Plug Features& Cofltrols Parking Brake Function Features& CefltrolsAutomatic Controlled Traction Irregular Voltage Dashboard Display FunctionsFuel Gauge Starting The Engine General Operating SafetySlope Operation Adding FuelWheel Drive Operation OperatiflgtheTractorMowing in Reverse Attachment Operation in ReverseGeneral Using Inboard HydraulicsPushing The Tractor By Hand Hydraulic System FunctionsAuxiliary Hydraulics Angle Left Angle Right Using Auxiliary HydraulicsLocking The Hitch Max. Attachment WeightAttachment Weight Limit OperatJflgtheTractorHitch Arms Installation Engine Speed Selection Connecting a Drive ShaftChecks Before Starting Starting & Stopping the PTOAttachment Recommendations PTO BOX Output Speed & Horsepower OutputRemoving the Mower Deck Mower Deck Removal & installationMower Electrical Connection Installing the Mower DeckAttaching a Trailer Volt Power OutletStorage Use Safety iTEMSEvery HoursChange Engine Coolant Clean RadiatorClean Transmission Oil Cooler Check Engine Coolant Level Drain Fuel Separator RegularMaintenanceTransmission Fluid Check Dip Stick Check Transmission Oil LevelCheck Front Axle Oil Level Change Transmission Oil & filter17ram Drain Plug Check Mower Deck Gear Box Oil Safety Interlock System CheckBlade Brake Check Size Tread PSi Battery MaintenanceCleaning the Battery and CabJes Check Tire PressuresEvery 25 Hours LubricationGrease Deck Lubrication Every 10 Hours Injury Servicing The Mower BladesSpring Washer Capscrew RegularlVlaifltenance Engine will not turnover or start Troubleshooting, Adjustment,& ServiceTractor Troubleshooting Cont TroubJeshootin9oAdjustment,& ServiceMower will not raise Seat Adjustment TrouhJeshooti&q,Adjustment,& ServiceSeat Slide Adjustment Headlight Replacement Teouhleshootin9oAdjustment,& ServiceTaillight & Dash Light Replacement Hair Pin Upper Position TroubJeshooti&j,Adjustment,& ServiceMower Adjustments Gauge Wheel AdjustmentSpacer Leveling The MowerDrive Idler Center TpouhJeshootin9oAdjustment,& ServiceMower Belt Replacement Mower Drive Belt Replacement4WD DiMENSiONS27 HP Briggs Stratton Manuals Replacement Parts TechnicalMaintenance Items Accessories