Cub Cadet 7254 Lubrication and Maintenance Chart, Operation to Service Intervals Be Performed

Page 29

LUBRICATION AND MAINTENANCE CHART

Ref.

Operation to

Service Intervals

No.

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

be Performed

Check Engine Oil Level

Check Air Cleaner

Check Engine Coolant Level

Check and Clean Radiator

Screen and Oil Cooler Fins

Clean Air Cleaner Foam

Element

Change Engine Oil and Replace

Oil Filter

Retorque Front and Rear Wheel Bolts

Check Transmission Oil Level

Replace Hydraulic and

Hydrostatic Oil Filters

Replace Hydraulic/Hydrostatic

Oil

Replace Air Cleaner Paper

Element

Grease Drive Shaft (both ends)

Grease FWD Drive Shaft (both ends)

Grease Front Axle Pivot (front and rear lube fittings)

Check Oil Level of Front Axle AND Final Reduction Gear Cases (both sides)

Grease Power Steering Cylinder (both ends)

Change Oil in Front Axle AND Final Reduction Gear Cases (both sides)

Grease Three Point Lift Shaft Clean and Re-gap Spark Plugs Change Engine Coolant

Check Radiator Hoses and Fan Belt

Check Fuel Filter

Before each use

Every 10 Hours

first

8

hrs.

first

10

hrs.

Every 25 Hours

first

25

hrs.

Every 50 Hours

Every 100 Hours

Every 200 Hours

Every 300 Hours

or

yearly

Every 400 Hours

Before Storage

More often when operating under dusty conditions.

29

Image 29
Contents Operator’s Manual Important Read Safety Rules and Instructions CarefullyPage To the Owner Table of ContentsCalling Service Information Rops Information Plate Recording Model and Serial Number InformationTractor Model Plate General Operation Important Safe Operation PracticesChildren Slope OperationOperating the PTO Do notService Safety Frame RopsStarting AID Safety LabelsFAN Warning Label Located on Each Side of Radiator Keep HandsRoll Over Warning Label Located on RIGHT/REAR Fender Battery Warning Label Located Under HoodPTO Warning Label Located on Rear PTO Shield Floorboard and Dash Panel Mounted Controls Controls and FeaturesIgnition Switch PTO SwitchSeat Adjustment Lever Steering WheelHeadlight Switch Hazard Light SwitchDifferential Lock Pedal Parking Brake LeverEngine Coolant Temperature Light Battery Indicator LightParking Brake Indicator Light PTO Indicator LightPTO Reverse Override Switch Fender Mounted Conrtols and FeaturesFuel Fill Cap PTO Selection LeverCup Holder Transmission Hi/Lo Range Shift LeverHand Holds Amber Hazard LightsOperation Safety Interlock SystemRollover Protective Structure Rops Fueling the TractorCold Weather Starting NEW Tractor BREAK-IN ProceduresStarting the Engine Stopping the Engine Using Jumper Cables to Start the EngineDriving the Tractor Driving on SlopesStopping the Tractor Using the FORWARD/REVERSE PedalUsing the HI/LO Range Shift Lever Using the Hydraulic Lift Lever Using the Differential Lock PedalEngaging the PTO Using the PTO Selection LeverUsing the Hitch Plate Using the PTO Reverse Override SwitchUsing the Three Point Hitch LightingOn Demand Four Wheel Drive Tractor WeightingAdjusting the Seat AdjustmentsAdjusting the Seat Belt Three Point Hitch AdjustmentsCheck the TOE-IN AS Follows Adjusting Front Wheel TOE-INAdjusting Hydraulic Lift Feedback ROD Adjusting the BrakesGeneral Information MaintenanceLubrication Table 11 5 Operation to Service Intervals Be Performed Lubrication and Maintenance ChartGeneral Battery Information Accessing the Engine CompartmentBattery Storage Battery RemovalBattery Maintenance Hazard Bulb Replacement Head Light Bulb ReplacementTail Light Bulb Replacement Accessing the Fuse Center Instrument Panel Bulb ReplacementServicing Electrical System Instrument Panel FusesChecking TRANSMISSION/HYDRAULIC System OIL Level Main FuseHazard Light Flasher Relay Changing TRANSMISSION/HYDRAULIC System OIL Initial Break-In Period Filter Change Changing Front Axle and Final Reduction Gear Case OIL Check Front Axle OilCheck Final Reduction Gear Case Oil Lubrication of Main Drive Shaft Maintenance of the Rollover Protective Structure RopsLubrication of FWD Drive Shaft Wheel Bolt TorqueIf storing the tractor for 30 days or more Tire MaintenanceTractor Storage Front of Engine Using a fuel stabilizerEmptying the fuel system Removing the Tractor from StorageEngine Information and Maintenance Limited Liability Cleaning the Engine Engine MaintenanceCleaning the Radiator Screen and Radiator Before servicingChanging the Engine OIL and Filter Adding Engine OILChecking Engine Coolant Level Changing the Engine Coolant Changing the AIR CleanerInspection of Cooling System Hoses Servicing the Paper Element Servicing the Foam PrecleanerServicing the Spark Plugs Changing the Fuel FilterSpecifications General Dimensions Power Take-OffHydraulic Lift System BrakesDescription Optional Equipment and AccessoriesPage CLEVELAND, Ohio CUB Cadet LLC Post Office BOX