SERVICING THE BATTERY
General Battery Information
WARNING:
•Battery posts, terminals and related accessories contain lead and lead compounds. Wash hands after handling.
•Battery acid must be handled with great care, as contact with it can burn and blister the skin. It is advisable to wear protective clothing (goggles, rubber gloves and apron) when working with acid.
•Should battery acid accidentally splatter into the eyes or onto the skin, rinse the affected area immediately with clean cold water. If there is any further discomfort, seek prompt medical attention.
•If acid spills on clothing, first dilute it with clean water, then neutralize with a solution of ammonia/ water or baking soda/water.
•Because battery acid is corrosive, do not pour it into any sink or drain. Before discarding an empty electrolyte container, rinse it thoroughly with a neutralizing solution.
•NEVER connect (or disconnect) battery charger clips to the battery while the charger is turned on, as it can cause sparks.
•Keep all sources of ignition (cigarettes, matches, lighters) away from the battery. The hydrogen gas generated during charging can be combustible.
•As a further precaution, only charge the battery in a well ventilated area.
•Always shield eyes and protect skin and clothing when working near batteries.
WARNING: Batteries contain sulfuric acid and may emit explosive gases. Use extreme caution when handling batter- ies. Keep batteries out of the reach of children.
Battery Removal
WARNING: Battery posts, terminals and related accessories contain lead and lead compounds. Wash hands after handling.
The battery is located at the front of the tractor behind the grill, just forward of the radiator.
To remove the battery:
•Open the grill as described previously.
•Remove the two nuts and the battery
Hex |
|
| Battery | Hold |
Nut |
|
| Down Strap | |
|
| |||
Battery
Hold
Down
Rod
Figure 74
•Loosen the cable clamp of the negative battery lead, then lift the negative cable off the negative battery post. Move the cable away from the nega- tive battery post.
•Repeat the above procedure to remove the cable from the positive battery post.
•Carefully lift the battery out of the tractor.
Install the battery by repeating the above steps in the reverse order.
WARNING: Always connect the positive lead to the battery before connecting the negative lead.
Battery Maintenance
•Check the battery occasionally to make certain it is tightly fixed in its battery tray.
•Make certain the battery vent caps are tightened securely in the vent holes.
•Spray the terminals and exposed wire with a battery terminal sealer, or coat the terminals with a thin coat of grease or petroleum jelly, to protect against corrosion.
•The battery should be kept clean. Any deposits of acid should be neutralized with baking soda and water. Be careful not to get this solution in the cells.
WARNING: Never remove any of the battery vent caps while the engine is running.
46