Husqvarna 4421-G/GX/GXL, 4421-D/DX/DXL owner manual Disabling the Vehicle

Page 14

General Warnings

WARNING

•Follow the procedures exactly as stated in this manual, and heed all DANGER, WARNING, and CAUTION statements in this manual as well as those on the vehicle.

•Do not leave children unattended on vehicle.

•Children requiring a child safety seat must not ride on the vehicle. Comply with state and local laws pertaining to child safety.

•The driver and passenger must be restrained at all times with the seat belts provided to help prevent injury in the event of sudden braking, collision, or roll-over.

•No more than one person per bucket seat at one time. No more than two persons per bench seat at one time. Do not allow people to ride in any part of the vehicle that is not equipped with a seat and a safety belt. Do not allow a passenger to hold a child in his or her lap while the vehicle is moving.

•Prior to leaving the vehicle unattended or servicing the vehicle, set the park brake, place the Forward/Reverse handle in the NEUTRAL position, turn the key switch to the OFF position, and remove the key. Chock the wheels when servicing the vehicle.

•Improper use of the vehicle or failure to properly maintain it could result in decreased vehicle performance, severe personal injury, or death.

•Any modification or change to the vehicle that affects the stability or handling of the vehicle, or increases maximum vehicle speed beyond factory specifications, could result in severe personal injury or death.

•Check the vehicle for proper location of all vehicle safety and operation decals and make sure they are in place and are easy to read.

•For vehicles with cargo beds, remove all cargo before raising the bed or servicing the vehicle. If the vehicle is equipped with a prop rod, ensure that it is securely engaged while bed is raised. Do not close bed until all persons are clear of cargo bed area. Keep hands clear of all crush areas. Do not drop cargo bed; lower gently and keep entire body clear. Failure to heed this warning could result in severe personal injury or death.

•Only trained technicians should service or repair the vehicle. Anyone doing even simple repairs or service should have knowledge and experience in electrical and mechanical repair. The appropriate instructions must be used when performing maintenance, service, or accessory installation.

•To avoid unintentionally starting the vehicle disconnect battery and spark plug (Gas only) wires. See Disconnecting the Battery – Gasoline/Diesel Vehicle on page 13.

•Frame ground – Do not allow tools or other metal objects to contact frame when disconnecting battery cables or other electrical wiring. Do not allow a positive wire to touch the vehicle frame, engine, or any other metal component.

•Wear safety glasses or approved eye protection when servicing the vehicle. Wear a full face shield and rubber gloves when working on or near batteries.

•Do not wear loose clothing or jewelry such as rings, watches, chains, etc., when servicing the vehicle.

•Use insulated tools when working near batteries or electrical connections. Use extreme caution to avoid shorting of components or wiring.

•When servicing the vehicle with part of the vehicle on jack stands, do not operate the engine with the Forward/Reverse handle in either the FORWARD or REVERSE position. The all-wheel drive system will engage any wheel(s), front or rear, with traction (Figure 3, Page 13).

DISABLING THE VEHICLE

1.Set the park brake.

2.Turn the key switch OFF and remove the key.

3.Place the Forward/Reverse control in the NEUTRAL position.

4.In addition, chock the wheels if servicing or repairing the vehicle.

Page 12 HUV 4421 Owner’s Manual

Page 13 Page 15
Image 14
Page 13 Page 15
Contents 4421-G/GX/GXL Gas 4421-D/DX/DXL Diesel Utility Vehicles Page Page Foreword Table of Contents Vehicle Specifications Warranties Safety Decal and Feature Identification ALL HUV 4421 TWO Passenger Models 2412364 ALL HUV 4421 Four Passenger Models 2413366 Practice Safety Proposition 65 State of CaliforniaSafety Details General WarningsDisabling the Vehicle Disable the vehicle. See Disabling the Vehicle on Disconnecting the Battery GASOLINE/DIESEL VehiclesConnecting the Battery GASOLINE/DIESEL Vehicles Recycling LEAD-ACID BatteriesGeneral Information Model IdentificationControls and Indicators Serial Number DecalInstrument Panel Gasoline Vehicles FORWARD/REVERSE Control KEY Switch Gasoline VehiclesKEY Switch Diesel Vehicles Accelerator PedalPark Brake Steering Adjustment LockBrake Pedal LOW OIL Warning Light Volt Accessory OutletHIGH-TEMPERATURE Warning Light Diesel Vehicles only Fuel GAUGE/HOUR MeterROLL-OVER Protective Structure and Seat Belts Roll-Over Protective Structure and Seat BeltsSeat Latch and Adjustment PRE-OPERATION and Daily Safety Checklist See Vehicle Specifications onDriving Instructions Performance InspectionStarting the Vehicle ALL-WHEEL Drive AWD Operation Parking and Leaving the Vehicle BED Latch and Prop RODStopping the Vehicle See General Warnings onLoading and Unloading Cargo Bed LatchVehicle Load Capacities Towing with the Vehicle Transporting on a TrailerStorage Preparing the Vehicle for Extended Storage Fuel Shut-off ValveMaintenance Returning the Stored Vehicle to ServicePeriodic Service Schedule Periodic Service Schedule Regular Interval Kawasaki gasoline engines Adjust valve Periodic Lubrication Schedule Lubrication Points Gasoline Vehicles Brake Fluid Reservoir Brake FluidEngine OIL Level Check Engine OILOIL Pressure Gasoline Engine Engine OIL and Filter Change Engine Oil DrainingEngine Oil Drain Plug and Pan Gasoline Remove Engine Oil Filter OIL Viscosity Engine Oil FillingGearcase Lubrication Front differentialTransmission Rear differentialEngine Coolant Diesel Vehicles Engine Coolant Level CheckAIR Intake System AIR Filter ReplacementAir Filter Installation Air Filter RemovalFueling Instructions Biodiesel Fuel Diesel Vehicles onlyDraining Water from Fuel Filter Diesel Vehicles OnlyBattery Fuel FilterRemove the driver-side seat Using a Booster Battery Jump Starting General Warnings onCleaning the Vehicle Jump StartingMUD Tire Option AccessoriesElectric Winch Accessory Subsequent Owner Registration Vehicle Specifications GXP DXP DXLLiquid Capacities Tire Pressure Warranty WarrantiesCalifornia Emission Control Warranty Statement HOW to Make a Warranty ClaimHusqvarna Explanation of Emission Control Warranty Systems Covered Parts Description Page Page Page 103472526
Top Page Image Contents