Desa Rgh3000, Rgh3000pr, Rgh5500a, Rgh5500aie, Rgh7500aie, And Rgh11000aie Handles TOP Cover

Page 8

®

PORTABLE GASOLINE GENERATORS

HANDLES AND

TOP COVER

(Model RGH11000AIE)

Follow the steps below to attach the handles and top cover to Model RGH11000AIE:

1.Remove the two bolts, lock nuts, and washers holding side panels to control panel end of roll cage. Insert bolts with washers through two holes in the handle and then back through roll cage and side screen panels (See Figure 8). Tighten the lock nuts against the side screen panels.

2.Place top cover on top of generator roll cage with notch on control panel side. Use four #8 sems screws provided to attach cover to roll cage (See Figure 9).

Roll Cage

Bolts Washers

Handle

Lock Nuts

 

Figure 8 – Attaching Handles to Roll Cage

SEMS Screws

Top Cover

SEMS

Screws

Figure 9 – Attaching Top Cover to Roll Cage

BATTERY

(Models RGH5500AIE, RGH7500AIE, and RGH11000AIE)

WARNING: Battery gives off explosive gases. Keep sparks, flames, and cigarettes away. Do not remove or install battery cables when engine is cranking or running. Only service or use battery in a well-vented area.

WARNING: Battery contains sulfuric acid. Contact with skin or eyes may cause severe burns. Do not tilt generator with battery in- stalled. Tilting could cause battery acid to spill. Wear protective cloth- ing and face shield when servic- ing. Keep out of children’s reach.

•If battery acid gets on your skin, wash with water.

•If battery acid gets in your eyes, flush with water at least 15 min- utes. Call a doctor at once. Battery acid is poisonous.

•Ifswallowed,drinklargeamounts of water or milk. Follow with milk ofmagnesiaorvegetableoil.Call a doctor at once.

CAUTION: If you remove bat- tery, insulate the red, positive (+) batterycableterminal.Insulatewith electrical tape. Exposed terminal may spark when generator runs.

IMPORTANT: Make sure battery connec- tions are the correct polarity. Electric start generators use negative ground, 12-volt DC starting system.

Models RGH5500AIE, RGH7500AIE, and RGH11000AIE have an electric starter. A battery is not supplied with generator. You must provide a 12-volt, 32-amp-hour bat- tery. The positive and negative battery cables are supplied with generator. You must in- stall these cables before mounting battery.

Always wear safety glasses when working with battery. Make sure battery terminals are clean. Make sure cable connections are tight.

Always shut down engine before removing or attaching battery cables. Always remove the negative (–) cable first. Always attach negative (–) cable last.

INSTALLING BATTERY CABLES TO ENGINE

1.Attach the red, positive (+) battery cable to the starter solenoid on engine (see Figure 10). The starter solenoid is located directly above the starter on Model RGH11000AIE. This cable is factory installed.

CAUTION: Do not over tighten positive terminal on starter sole- noid. Positive terminal could ro- tate and cut into negative termi- nal, causing a short.

2.Attach the black, negative (–) battery cable to the engine block. Use the bolt, nut, and two washers provided with the battery cables. Use long mounting hole on oppo- site side of engine from starter solenoid. Attach cable as shown in Figure 11.

Starter

Solenoid

Red, Positive (+)

Battery Cable

Figure 10 - Connecting Red, Positive (+) Battery Cable to Engine Starter Solenoid (Model RGH7500AIE Shown)

Black,

Negative (–)

Battery Cable

Figure 11 - Connecting Black, Negative (-) Battery Cable to Engine Block (Model RGH7500AIE Shown)

8

106815

Page 7 Page 9
Image 8
Page 7 Page 9
Contents OWNER’S Operation and Installation Manual Portable Gasoline GeneratorsSafety Information Portable Gasoline GeneratorsProduct Identification If engine speed changes greatlyHigh and LOW Temperature Operation General InformationUnpacking VentilationRGH3000PR RGH5500AIE RGH7500AIE RGH11000AIE SpecificationsModel Generator Features Full Power Selector SwitchOIL Alert System AUTO-IDLE SystemEngine OIL FuelReceptacle Circuit Breaker Engine Circuit BreakerHandles TOP Cover BatteryInstalling Battery Cables to Engine Mounting Battery to Generator Recommended Minimum Wire Gauges AWG for Extension CordsExtension Cords Generator GroundingStandby Installation to Home or Building Chart 1 Typical Electric Appliance WattagesChart Determining Electrical Load for GeneratorPower Cord and Plug Requirements Using ReceptacleOperation General InformationPrestart StartingAdjusting the Idle Speed AUTO-IDLE OperationStopping Engine Disconnecting Electric LoadsHigh Altitude Operation Adding Electrical Loads Storage Maintenance and RepairsTroubleshooting Electrical Component Specifications Wiring DiagramsWiring Diagram, Model RGH5500AIE Wiring Diagram, Model RGH11000AIE Technical Service AccessoriesReplacement Parts Servicing the EngineIllustrated Parts List For Models RGH3000 RGH3000PR Alternator AssemblyKEY Part Number Description QTY Parts Available not ShownAlternator Assembly For Models RGH5500A RGH5500AIE,Part Number for Model KEY RGH5500AIE RGH7500AIE Description QTYFor Model RGH11000AIE Alternator Assembly KEY Part Description Number QTYFor Models RGH3000 RGH3000PR Roll Cage WP-5CPortable Gasoline Generators Only on RGH5500AIE electric start models Tank and Roll Cage For Model RGH11000AIE Fuel Tank and Roll Cage WP-4CUnder Replacement Parts on For Models RGH5500A RGH5500AIE, RGH7500AIE Control PanelListed under Replacement Parts on For Model RGH11000AIE Control PanelFor Solenoid and Control Board Assemblies and Mounting For Solenoid and Control Board Assemblies and Mounting Keep this Warranty International

Rgh3000, Rgh3000pr, Rgh5500a, Rgh5500aie, Rgh7500aie, And Rgh11000aie specifications

Desa is recognized for its innovative heating technology products, and among its offerings are the Rgh series, which includes the Rgh3000, Rgh3000pr, Rgh5500a, Rgh5500aie, Rgh7500aie, and Rgh11000aie. These models embody the latest advancements in performance and energy efficiency, catering to a variety of heating needs in both residential and commercial applications.

The Rgh3000 and Rgh3000pr are compact yet powerful solutions designed for smaller spaces. They are equipped with high-efficiency heating elements that allow for quick warmth distribution, making them ideal for personal rooms or as supplemental heating sources. The Rgh3000pr variant includes programmable features, enabling users to set specific heating schedules, optimizing energy use and offering cost savings over time.

For larger areas, the Rgh5500a and Rgh5500aie models provide enhanced heating capacity without sacrificing efficiency. The Rgh5500aie features integrated smart technology, allowing users to control the heater remotely via smartphone applications. This model also boasts increased insulation and improved heat retention capabilities, ensuring that warmth is maintained longer while reducing energy consumption.

Moving up the line, the Rgh7500aie offers even greater versatility with its multi-zone heating options. Users can create tailored heating environments based on individual room requirements, maximizing comfort and minimizing energy wastage. The Rgh7500aie model also incorporates advanced air filtration, improving indoor air quality alongside heating functionality.

The Rgh11000aie stands at the pinnacle of this series, providing unparalleled heating power suited for large commercial spaces or expansive homes. Its energy-efficient design is complemented by cutting-edge smart technology, allowing for real-time temperature monitoring and adjustments. This model is also equipped with advanced safety features, including automatic shut-off mechanisms, ensuring peace of mind during operation.

All these models share a commitment to sustainability, utilizing Eco-friendly materials and energy-efficient technologies. Their sleek designs seamlessly integrate into various decor styles, making them not only functional but aesthetic additions to any environment. With options catering to differing heating needs, Desa’s Rgh series stands out in delivering modern heating solutions that prioritize user convenience, efficiency, and environmental responsibility.
Top Page Image Contents