Generac 4582, 4451 owner manual Wiring Diagram Drawing No E0228

Page 24

Section 6 — Electrical Data

Commercial-Industrial-Residential Portable Generator System

Wiring Diagram – Drawing No. 0E0228

																BEARING		BA
																TO			4	0
				STATOR												CLOSES T
																77
													6		55	66		10	11	12	PIN #
												77A	2			8	9
																7
									11S	44S	55A	66A	4	5	6
								22					3
												2
								11	44		1
								11
						22												2
						22																CB1
																	55
												44
						11
				IDLE CONTROL	TRANSFORMERS					RED						BLK	BLK	TB1	TB2
					22		11							83 167	229	15B	0				86
									44A
												44
120/240 V 50A OUTLET			GREEN	X Y	WHITE						11				ON	OFF					44A	83
																50A C.B.
		0	0				22	11A	44	44 44		11	11	11				11A
						22							44
					0				0			44		11
														11
120/240V 30ATWISTLOK			G		Y
120/240V 30ATWISTLOK			X	WHITE				22		44B	C.B.			30A	C.B.
										30A
						22		0											11
										11B						0			11
A		22														0
A
120V/20	GFCI				22	0	0														44
				2	4	5											44
22			WHITE		WHITE			22	22			20A	C.B.							11
22				1	3			22	22			20A	C.B.							11
				LOAD	LINE
				HOT	HOT
						44C
		22
A
120V/20	DUPLEX			22	22	0
				2	4	5											11
			WHITE		WHITE								C.B.
												20A	C.B.
				HOT	HOT
				1	3
								0
											11C
									22
									0
A		TWISTLOK
120V/30		TWISTLOK			0	0
				G													11
			WHITE								11D	30A	C.B.
					22
120V/30 A		TWISTLOK		G	0	0			22							44					WIRING
													C.B.								E
			WHITE	22	22			44D				30A	C.B.								ENGIN
				22

						1PIN	2PINVOLTAGE	3PIN	4PIN	5PIN	6PIN			R1					LEGEND BRUSH-BAASS EMBLY	5AMP-CB1AUT O RESE T BREAKER ENGINE-DSHU TDOWN DIODE	V600-D212A DIODE	FUSE10A-F1	UELF-FSSSHU T OFF SOLENOID ROUNDG-GND BAR	IGNITION-IM1 MODULE, CYL. 1 GNITIONI-IM2 MODULE, CYL. 2 OWL-LOPOIL PRESSU RE OHM,25-R1 2 5W RESISTOR STARTER-SCCONTACT OR TARTERS-SCR CONTAC TORRELAY STARTER-SMMOTOR	PARKS-SP1PLUG, CYL. 1 PARKS-SP2PLUG, CYL. 2	TARTS-SSR/ STOP RELAY	-2TBTB1,TERMINAL BLOCK
								REGULATOR
						0					6				D2					BATTERY CHARGE	ER			ER
							162	11S	4	44S										BATTERY CHARGE	RECTIFI			BATTERY CHARGE RECTIFI
											4				4		4		14
6																	4		14
			77											77									77	66
66															66
66A					77A													77A			66A
									4
											0
													14							15				13A
				162									0						14	15
	55			162												55
44S 55A	55													55A		55
44S 55A	11S													55A
1		/		B.																	10A AUTO	RESET BKR
12 11 10 9 8 7 6 5 4 3 2	J2	ELECTRONIC GOVERNOR		ENGINE SHUTDOWN P.C.					J1		14												OUTLET	0	15A
											14												12Vdc
																		0
												86
											0								14
ON/OFF IDLE	CONTROL	SWITCH					229	14			167
					0								0
				15B						0											14
														0									0
																							0
		18	4	8	12									15					55A
14			2	6	10	SSR	14								0	0			55
							13			15
			1	5	9					15
						15			0					15				GND					14
																	0
															0						0
															0						0
															0				0
															0
											0				0
												0
															F1
														86								SCR		0
						18								86					87	87a 85		30
																				86
								15				0	167	15	13	14	17	16	15	15	13			0
						1		2				3	4	5	6	7	8	9		10	11		12	PIN #
								15					167
												0													16
																								13
																									13
																		15
											0				17
GOVERNOR ACTUATOR						IC					0	(START)	RUN	STOP	86	14							0	RED	SM		SC
																		FSS
															LOP				0
							D
											IM1			D	IM2										- +	12V	BATTERY
																								BLACK
								SP1						SP2

22

Image 24

Contents Owner’s Manual Safety Rules General Information Introduction Important Safety Instructions General HazardsElectrical Hazards Explosion HazardsFire Hazards Assembly Accessory BOXUnpacking Assembling the Wheel KITBattery Connection Handle AssemblyOperation Know the GeneratorCord Sets and Connection Plugs 1 AC, 20 AMP, Duplex Receptacle2 120V AC, 20 AMP, Gfci Receptacle 5 12 Volt DC, 10 AMP Receptacle Provided. This receptacle can not recharge 6 Volt batteriesHOW to USE the Generator Connecting Electrical LoadsDON’T Overload the Generator Grounding the GeneratorWattage Reference Guide Before Starting the GeneratorAdding Engine OIL To Start the Engine Adding GasolineAutomatic Idle Control Cold Weather OPERATION/ DE-ICERLOW OIL Pressure Shutdown System Stopping the EngineCharging a Battery To recharge 12 Volt batteries, proceed as followsMaintenance Schedule Product SpecificationsGenerator Specifications Engine SpecificationsGeneral Recommendations Service AIR Cleaner Clean Spark Arrestor ScreenReplacing the Spark Plug Adjusting Valve Clearance To adjust valve clearanceStorage General Long Term StorageOther Storage Tips Troubleshooting Commercial-Industrial-Residential Portable Generator System Commercial-Industrial-Residential Portable Generator System Wiring Diagram Drawing No E0228 Schematic Drawing No E0229-A GT-990 & GT-760 Engine Page 1 Drawing No E8589E Item Part NO. QTY. Description GT-990 & GT-760 Engine Page 2 Drawing No E8589E QTY Description Generator Drawing No D4488-D QTY. Description Control Panel Drawing No E0227B Part NO. QTY. Description Frame, Handle & Wheel Kit Drawing No E0695-A QTY Description California Emission Control Warranty Statement Emission Control System Warranty Warranty Schedule Generac Power SYSTEMS, INC. P.O. Box 297 Whitewater, WI