Briggs & Stratton 190839GS owner manual Before Initial START-UP, Engine Oil, Battery Connection

Page 13

Briggs & Stratton Power Products Home Generator System

Owners Manual

BEFORE INITIAL START-UP

Engine Oil

This engine is shipped from the factory filled with the recommended oil. Before starting the engine, check oil level and ensure that engine is serviced as described in the engine owner’s manual.

CAUTION! Any attempt to crank or start the engine before it has been properly serviced with the recommended oil will result in an engine failure that is not covered under warranty.

Oil Considerations

Your Home Generator System is equipped with an engine that has been pre-run at the factory and does not require the traditional “break-in” procedure.

In order to provide a greater “backup” capability, the system is filled with synthetic oil (API SJ/CF 5W-30W).This allows for system operation in the widest range of temperature and climate conditions.

NOTE: The use of synthetic oil DOES NOT alter the required oil change intervals described in the engine owner’s manual.

Battery Connection

The Home Generator System is supplied with a 12 Volt DC 18 Amp-Hour sealed rechargeable battery. It is installed in the unit and the battery cables are connected at the factory.The unit’s 15 Amp fuse has been removed for shipping (this prevents the unit from starting).

CAUTION! Do Not install the 15 Amp fuse until all plumbing and wiring has been completed and inspected. Failure to install the fuse as described in the Installation Manual could cause the engine to start.

NOTE: With the battery installed, utility power supplied to the Automatic Transfer Switch, and the unit in AUTO mode, the battery receives a trickle charge while the engine is not running.The trickle charger cannot be used to recharge a battery that is completely discharged.

Gaseous Fuel System

•Ensure that all fuel pipe connections are tight, secure and without leaks.

•Ensure that all shutoff valves are OPEN and that adequate pressure is available.

If you smell ‘raw’ gaseous fuel (natural or LP) near the unit, immediately turn off the gas supply to the generator. Contact your gas utility or the system installer for assistance in determining the source of the smell.

The AUTO/OFF/MANUAL Switch

This three-position device is referred to herein as “AUTO/OFF/MANUAL”. It is found on the control panel, as shown earlier, and is used as follows:

•“AUTO” position is the normal operating position. If a utility power outage is sensed, the system will start the generator, let it reach stable operating speed, then connect generator power to the transfer switch. When utility power is restored, the system reconnects utility power to the transfer switch, lets the engine ‘cool down’, shuts off the generator, and waits for the next utility power outage.

•“OFF” position turns off a running generator, takes the system out of Automatic mode and resets faults.The unit will not exercise, but the ‘Set Exercise’ setting is not lost.

•“MANUAL” position starts the engine but does not disconnect utility power from the transfer switch. It is used for maintenance or diagnostic functions.

CAUTION! With the switch set to AUTO, the engine may crank and start at any time without warning. Such automatic starting normally occurs when utility source voltage drops below a preset level or during the normal exercise cycle.To prevent possible injury that might be caused by such sudden starts, always set the AUTO/OFF/MANUAL switch to OFF and remove the 15 Amp fuse before working on or around the generator or transfer switch.

The other controls and devices installed on the control panel are described on page 11,“Know Your System Control Panel”.

13

Page 12 Page 14
Image 13
Page 12 Page 14
Contents Call Home Standby Helpline Manual del Propietario Manuel de lUtilisateurTable of Contents Safety Rules Briggs & Stratton Power Products Home Generator System Introduction Installation AssistanceOwner Orientation For the Home or Business OwnerGenerator Location Power Decrease at High Altitude or High TemperatureFuel Factors Generator ClearancesEssential Circuits Typical Completed Automatic Transfer Switch InstallationEssential Circuit Selection Device Running WattsUnpacking Shipment ContentsDelivery Inspection Know Your Backup Generator LED Know Your System Control PanelTo Remove an Access Door Access DoorsTo Install an Access Door AUTO/OFF/MANUAL Switch Battery ConnectionBefore Initial START-UP Engine OilAutomatic Operation Setting Exercise TimerChecking Automatic Operation Stopping the SystemTransfer Switch SpecificationsTo perform the Set Exercise procedure GeneratorFault Detection System MaintenanceOil Temperature High Power During Fault ConditionLow Voltage Engine Fail To StartTo Clean the Generator Generator MaintenanceStorage If You Call the FactoryTroubleshooting Briggs & Stratton Power Products Home Generator System Briggs & Stratton Power Products Home Generator System Unit Schematic Diagram Unit Wiring Diagram Transfer Switch Schematic Diagram Transfer Switch Wiring Diagram Unit Exploded View Qty. Description Unit Parts ListEnclosure Exploded View Part Not Illustrated Enclosure Parts ListInsulation SET Exploded View Insulation SET Parts List CAP Alternator Exploded View and Parts ListRESISTOR, 25W, .5 OHM Control Panel Exploded View and Parts ListTransfer Switch Exploded View Loadcenter Transfer Switch Parts ListManual del Propietario Tabla DE ContenidoAdvertencia Instrucciones DE SeguridadPeligro Precaución Orientación Para EL Propietario IntroducciónAsistencia para la instalación La instalación de los Sistemas de GeneradoresUbicación del Generador Factores Relacionados con el CombustibleDistancias Desde el Generador Selección de los Circuitos Fundamentales Circuitos FundamentalesTostadora Dispositivo Vatiaje deInspección al Momento de la Entrega DesempaqueContenido de la Caja El Sistema de Generador Doméstico incluye lo siguienteConozca SU Generador Doméstico Contador de Horas Fusible de 15 Amperios Conozca EL Panel DE Control DEL SistemaPara Retirar una Puerta de Acceso Puertas de AccesoPara Instalar una Puerta de Acceso Aceite de Motor Antes DEL Arranque InicialSistema de Combustible Gaseoso Interruptor AUTO/OFF/MANUAL automático/apagado/manualOperación Automática Configuración del Temporizador de PrácticaVerificación de la Operación Automática Paro del SistemaGenerador EspecificacionesConmutador de Transferencia Sistema de Detección de Fallas MantenimientoEnergía Durante una Condición de Falla Almacenamiento Mantenimiento DEL GeneradorPara Limpiar el Generador Si Llama a la FábricaReparacion DE Averias Manuel dUtilisation Table DES MatièresAvertissement Règles DE SécuritéLe contact de ces pièces risque de causer de graves brûlures Introduction Aide à lInstallationConseils AU Propriétaire Au Propriétaire Résidentiel ou CommercialFacteurs Relatifs au Combustible Emplacement de la GénératriceDégagement Autour de la Génératrice Circuits Essentiels Fils dalimentation Fils de signalSélection des Circuits Essentiels Appareil WattsVérification de la Livraison DéballageContenu de la Boîte Le Groupe Électrogène est Livré avec les Éléments SuivantsBatterie La position normale de fonctionnement est la position Portes dAccès Pour Installer une Porte dAccèsPour Enlever une Porte dAccès Huile à Moteur Avant LE Démarrage InitialBranchement de la Batterie Système de Combustible GazeuxVérification du Fonctionnement Automatique Fonctionnement AutomatiqueArrêt du Système Réglage de la Minuterie du Cycle dExerciceGénératrice CaractéristiquesCommutateur de Transfert Pour Exécuter la Procédure de Réglage du Cycle dExerciceSystème de Détection des Pannes EntretienAlimentation en Situation de Panne Remisage Entretien DU GénérateurCommunications avec le Fabricant Pour Nettoyer le GénérateurDépannage Remarques

190839GS specifications

Briggs & Stratton 190839GS is a versatile and powerful generator that caters to the needs of homeowners, contractors, and outdoor enthusiasts alike. Known for its reliability and performance, this generator is designed to provide a steady power supply during emergencies or when additional electricity is needed on job sites.

One of the standout features of the Briggs & Stratton 190839GS is its robust 8500 running watts and 10500 starting watts. This impressive wattage allows it to power several appliances, tools, and electronics simultaneously, making it an ideal choice for both residential and commercial applications. This makes it particularly useful during power outages, ensuring that essential devices like refrigerators, lights, and medical equipment continue to operate smoothly.

The generator is equipped with a powerful 420cc OHV engine that is engineered for durability and longevity. Its overhead valve engine design reduces emissions and enhances fuel efficiency while providing excellent performance. The engine's design also contributes to quieter operation, which is a significant advantage when using it in residential areas or during outdoor activities.

Mobility is another key characteristic of the Briggs & Stratton 190839GS. It comes with a rugged wheel kit and a collapsible handle, allowing for easy transportation and setup wherever power is needed. This portable design is perfect for taking to job sites, camping trips, or even tailgating events, ensuring that you have reliable power access whenever and wherever you require it.

The generator features a user-friendly control panel with multiple outlets, including 120V and 240V options, accommodating various devices and tools. The inclusion of a digital wattage display provides real-time monitoring of power consumption, enabling users to manage their load efficiently.

Safety is paramount, and the Briggs & Stratton 190839GS incorporates several safety features, including low oil shutdown, which prevents engine damage by automatically turning off the generator when oil levels are too low. Additionally, the generator's sturdy construction and weather-resistant design add to its longevity and ensure that it can withstand the elements.

Overall, the Briggs & Stratton 190839GS generator combines power, efficiency, portability, and durability, making it an exceptional choice for anyone in need of a reliable backup power source or portable electric supply. Whether for emergency use or recreational activities, this generator stands out in its category for delivering performance and peace of mind.
Top Page Image Contents