Poulan 422088, 96192002402 owner manual 01.03.002-A

Page 32

REPAIR PARTS SNOW THROWER - - MODEL NUMBER XT1053ES (96192002402)

DRIVE

6

	7
1b	4
8	3
	3
1b
7	1a
	1a

			KEY	PART	DESCRIPTION
		2	NO.	NO.	DESCRIPTION
		2	1	404923	AXLE ASSEMBLY (assy of 1a,1b)
			1	404923	AXLE ASSEMBLY (assy of 1a,1b)
5	3		1a	404307	AXLE SHAFT
5			1b	9465M1	ROLL PIN 3/16 X 1.50
	4		1b	9465M1	ROLL PIN 3/16 X 1.50
	4		2	402691	SPROCKET
6	01.03.002-A		3	174697	THRUST WASHER
			4	179830	BEARING
			5	146315	SCREW 5/16−18 X .625
			6	17490508	SCREW 5/16−18 X .500
			7	155443	KLIK PIN 1/4 X 1.50
			8	189282	SQUARE KEY

NOTE: All component dimensions given in U.S. inches. 1 inch = 25.4 mm

IMPORTANT: Use only Original Equipment Manufacturer (O.E.M.) replacement parts.

Failure to do so could be hazardous, damage your snow thrower and void your warranty.

32

Image 32

Contents Model Number Snow ThrowerSafe Operation Practices for Walk-Behind Snow Throwers Table of Contents Assembly / PRE-OPERATION HOW to SET UP Your Snow ThrowerParts Packed Separately in Carton Remove Snow Thrower from CartonInstall Speed Control ROD See Figs Unfold Upper HandleInstall Auger Control ROD See Figs Install Discharge Chute / Chute Rotater Head See FigInstall Chute Deflector Remote Control See Figs Check Tire PressureOperation Know Your Snow ThrowerPrimer Ignition KEYMeets A.N.S.I. Safety Requirements Deflector remote control lever used to changeHOW to USE Your Snow Thrower StoppingUsing the CLEAN-OUT Tool See Fig Power Steering Operation See FigTo Throw Snow See Fig To Move Forward and Backward See FigTo Adjust Skid Plates See Fig Before Starting the EngineCheck Engine OIL Level See Fig ADD Gasoline See FigSnow Throwing Tips To Start EngineBefore Stopping If Recoil Starter has FrozenMaintenance General RecommendationsBefore Each USE LubricationCleaning EngineService and Adjustments To Adjust Snow Thrower HeightChute Deflector Shear Bolts See FigTo Replace Belts See Fig Storage OtherTroubleshooting Exploded KEY Part Description Auger Housing Scraper BARCARRIAGEBOLT5/16−18X.625 Auger BearingAuger Assembly 30 LH Auger Assembly 30 RHDeflector Control Assembly Chute WeldmentDeflector Weldment Deflector SealLEVER/CABLE Rotator Assembly Rotator HeadRotator Pivot Bracket Pulley PivotLoop Handle LH Loop Handle RHLower Tube Pivot SupportSpacer RetainerKnob RED Handle KnobImpeller ROD Assembly Traction ROD AssemblyShifter ROD TOP Shifter ROD Bottom Wire Harness Console Panel Headlight Bezel Flood HeadlightRepair Parts Snow Thrower - Model Number XT1053ES Drive Speed Selector Assembly 43 402689 Drive Plate AssemblyEND Plate Washer01.03.002-A 423184X505 Engine Mount Plate KEY Part Description ENGINE, TECModel LH358SA-159628A Impeller Belt Belt CoverTraction Belt Cable Bracket LH Cable Bracket RHCover Wheel Driver Retainer RingWheel Lobe Clutch SlideSafety Ignition KEY 35062DECAL, DANGER, Deflector 181037DECAL, Danger Service Notes Limited Warranty