Land Pride PS25120 manual Table of Contents

Page 2

Table of Contents

Important Safety Information . . . . . . . . . . .1

Introduction . . . . . . . . . . . . . . . . . . . . . . . .7

Section 1: Assembly and Set-up . . . . . . . .8

Sling Brackets . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8 Three-Point Primary Seeder . . . . . . . . . . . . . . . . . 8 Pull-Type Primary Seeder . . . . . . . . . . . . . . . . . . . 9 Pull-Type Primary Seeder with End Wheels . . . . . 9 Pull-Type Primary Seeder with Front Wheels . . . 11

Section 2: Operating Instructions . . . . . .13

General Description . . . . . . . . . . . . . . . . . . . . . . . 13 Operating Check List . . . . . . . . . . . . . . . . . . . . . . 13 Tractor Requirements . . . . . . . . . . . . . . . . . . . . . 13 Front Wheel Pull-Type . . . . . . . . . . . . . . . . . . 13 Tractor 3-PointHook-Up . . . . . . . . . . . . . . . . . . . 13 Tractor Drawbar Hook-Up . . . . . . . . . . . . . . . . . . 14 Pull-Type and End Wheel Units . . . . . . . . . . . 14 Front Wheel Units . . . . . . . . . . . . . . . . . . . . . . 14 Tractor Hydraulic Hook-Up . . . . . . . . . . . . . . . . . 15 Bleeding Hydraulic System . . . . . . . . . . . . . . . . . 15 Operating Hydraulic Lift System . . . . . . . . . . . . . 15 Transporting . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15 Pull-Type, Front, or End Wheel Seeders . . . . . 15 Parking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16 3-Point Seeders . . . . . . . . . . . . . . . . . . . . . . . 16 Pull-Type, Front or End Wheel Seeders . . . . . 16 Seed Level Indicator . . . . . . . . . . . . . . . . . . . . . . 17 Agitator Attachment (Optional) . . . . . . . . . . . . . . . 17 General Operating Instructions . . . . . . . . . . . . 17

Small Grass Seeds Attachment (Optional) . . . . . . 32 Seed Rate Speed Change . . . . . . . . . . . . . . . . 32 Calibrating & Adjusting Seeding Rate . . . . . . . 32 Small Grass Seeds Attachment Seed Rates . . 33

Small Grass Seeds Attachment Metric Seed Rates 35

Agitator Attachment (Optional) . . . . . . . . . . . . . . . 37 Engaging & Disengaging the Agitator Sprocket 37 Calibrating and Adjusting Seed Rate . . . . . . . . 37 Coil Tines (Optional) . . . . . . . . . . . . . . . . . . . . . . 37 Height Adjustment . . . . . . . . . . . . . . . . . . . . . . 37 Danish Tines (Optional) . . . . . . . . . . . . . . . . . . . . 37 Height Adjustment . . . . . . . . . . . . . . . . . . . . . . 37 Walkboard (Optional) . . . . . . . . . . . . . . . . . . . . . . 38 Adjustment w/ Small Grass Seeds Attach . . . . 38 Adjustment w/o Small Grass Seeds Attach . . . 38

Section 4: Maintenance and Lubrication 39

Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39

Storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39

Lubrication . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39

Roller Chains . . . . . . . . . . . . . . . . . . . . . . . . . . 39

Wheel Arm Pivot Shafts . . . . . . . . . . . . . . . . . . 40

Wheel Bearings . . . . . . . . . . . . . . . . . . . . . . . . 40

Front and Rear Roller Bearings . . . . . . . . . . . . 40

Feeder Cup Drive Sprocket . . . . . . . . . . . . . . . 40

Drive Sprocket Hanger Bearing

(Small Grass Seeds Attachment) . . . . . . . . . . 41

Feeder Cup Drive Sprocket

(Small Grass Seeds Attachment) . . . . . . . . . . 41

Agitator Lockout (Agitator Attachment) . . . . . . 41

Section 3: Adjustments

18

Section 5: Options

42

Drive System

18

Small Seeds Attachment 313-113A

42

Roller Packing Wheels

18

Agitator Attachment 313-079A

42

Seed Broadcasting System

18

Coil Tine Track Removers 313-078A

42

Seed Rate Speed Change

18

Danish Tine Track Removers 313-077A

43

15 Bushel Speed Change

18

Walkboard 313-130A

43

30 Bushel Speed Change

18

Section 6: Specifications & Capacities . .

44

Calibrating & Adjusting Seeding Rate

20

Section 7: Features & Benefits

46

Seed Rate Charts for Ag Drive

21

 

 

Brome Grass Seed Rate Chart

23

Section 8: Troubleshooting

47

Metric Seed Rate Charts for Ag Drive

24

Section 9: Appendix

48

Metric Brome Seed Rate Chart

26

Torque Values Chart

48

Seed Rate Charts for Turf Drive

27

Tire Inflation Chart

48

Metric Seed Rate Charts for Turf Drive .

29

Warranty

49

 

 

© Copyright 2006 All rights Reserved

Land Pride provides this publication “as is” without warranty of any kind, either expressed or implied. While every precaution has been taken in the preparation of this manual, Land Pride assumes no responsibility for errors or omissions. Neither is any liability assumed for damages resulting from the use of the information contained herein. Land Pride reserves the right to revise and improve its products as it sees fit. This publication describes the state of this product at the time of its publication, and may not reflect the product in the future.

Land Pride is a registered trademark.

All other brands and product names are trademarks or registered trademarks of their respective holders.

Printed in the United States of America.

PS25120 Primary Seeder 313-156M

8/21/06

Page 1 Page 3
Image 2
Page 1 Page 3
Contents Primary Seeder Table of Contents Safety at All Times Practice Safe Maintenance Use Safety Lights and DevicesUse a Safety Chain Transport Machinery SafelyAvoid High Pressure Fluids Hazard Prepare for EmergenciesWear Protective Equipment Keep Riders Off Machinery818-003C 818-230C818-339C 818-229C818-337C 818-340C818-338C Owner Assistance Using This ManualApplication Parking Stand Installation Pre-Assembly ChecklistSling Bracket Installation Sling BracketsSpring Hose Loop Assembly Acremeter InstallationTongue & Turnbuckle Assembly Pull-Type Primary SeederWheel Bracket & Wheel Arm Assembly End Wheel Hydraulic SchematicPull-Type Primary Seeder with Front Wheels Accumulator AssemblyAccumulator Hydraulic Schematic Cylinder, Wheel Bracket & Wheel Arm Assembly Front Wheel Hydraulic SchematicTractor Requirements General DescriptionOperating Check List Tractor 3-Point Hook-UpFront Wheel Units Tractor Drawbar Hook-UpPull-Type and End Wheel Units Operating Hydraulic Lift System Tractor Hydraulic Hook-UpBleeding Hydraulic System TransportingPull-Type, Front or End Wheel Seeders ParkingPoint Seeders Agitator Attachment Optional Seed Level IndicatorSeed Level Indicator General Operating InstructionsSeed Broadcasting System Drive SystemRoller Packing Wheels Seed Rate Speed ChangeAg Drive Low RangeHigh Range Low Range High Range Turf DriveCalibrating & Adjusting Seeding Rate Seed Rate AdjustmentFescue Fine Blade, Turf Type Pounds per 1000 Square Feet Seed Rate Charts for Ag DriveFescue Fine Blade, Turf Type Pounds per Acre Rye Grass Annual Pounds per Acre Kentucky Blue Grass Pounds per AcreLovegrass Sand Pounds per Acre Rye Grass Perennial Pounds per AcreWheatgrass Western Pounds per Acre Brome Grass Seed Rate ChartWheatgrass Crested Pounds per Acre Clover White Metric Seed Rate Charts for Ag DriveClover Red Fescue Fine Blade, Turf Type Kilograms per HectareFescue K-31 Metric Brome Seed Rate Chart Seed Rate Charts for Turf Drive Bent Grass Pounds per Acre28 PS25120 Primary Seeder 313-156M Metric Seed Rate Charts for Turf Drive Fescue K-31Kilograms per Hectare Clover White Kilograms per 1000 Square MetersRye Grass Perennial Kilograms per HectareSmall Grass Seeds Attachment Optional Calibrating & Adjusting Seeding RateSmall Grass Seeds Seed Rate Adjustment Seed Rate Speed ChangeSmall Grass Seeds Attachment Seed Rates Bird’s-foot Trefoil Pounds per AcreMillet Pounds per 1000 Square Feet Lespedeza Unhulled Kilograms per 1000 Square MetersMillet Kilograms per Hectare Red Top Kilograms per HectareSmall Grass Seeds Attachment Metric Seed Rates Fescue K-31Kilograms per 1000 Square Meters Millet Kilograms per 1000 Square MetersCoil Tines Optional Calibrating and Adjusting Seed RateHeight Adjustment Danish Tines OptionalWalkboard Optional Adjustment w/ Small Grass Seeds AttachAdjustment w/o Small Grass Seeds Attach Lubrication MaintenanceStorage RequiredHours SeasonallyAgitator Lockout Agitator Attachment Drive Sprocket Hanger Bearing Small Grass Seeds AttachmentFeeder Cup Drive Sprocket Small Grass Seeds Attachment Coil Tine Track Removers 313-078A Small Seeds Attachment 313-113AAgitator Attachment 313-079A Danish Tine Track Removers 313-077A Walkboard 313-130APS25 Series Primary Seeder Bushel SeedersBushel and 30 Bushel Seeders Pull-Type with End Wheels Bushel and 30 Bushel Seeders Pull-Type with Front WheelsFeatures & Benefits Raising and lowering seeder is rough or Problem SolutionAcremeter doesn’t measure accurately Feed cup sprocket locked up or twistedTire Size Inflation Torque Values ChartTire Inflation Chart 5L x 15 8-Ply Rib ImplementWarranty Corporate Office P.O. Box Salina, Kansas 67402-5060 USA
Top Page Image Contents