Land Pride PS25120 manual Safety at All Times

Page 3

Land Pride

Table of Contents

Important Safety Information

These are common practices that may or may not be applicable to the products described in this manual.

Safety at All Times

Thoroughly read and understand the instructions given in this manual before operation. Refer to the “Safety Label” section, read all instructions noted on them.

Do not allow anyone to operate this equipment who has not fully read and comprehended this manual and who has not been properly trained in the safe operation of the equipment.

Look For The Safety Alert Symbol

The SAFETY ALERT SYMBOL indicates there is a

!safety precaution must be taken. When you see this symbol, be alert and carefully read the message that follows it. In addition to design and configuration of equipment, hazard control and accident prevention are dependent upon the awareness, concern, prudence and proper training of personnel involved in

the operation, transport, maintenance and storage of equipment.potential hazard to personal safety involved and extra

▲ Operator should be familiar with

all functions of the unit.

▲ Operate implement from the

driver’s seat only.

▲ Make sure all guards and shields

are in place and secured before

operating the implement.

▲ Do not leave tractor or implement

unattended with engine running.

▲ Dismounting from a moving

tractor could cause serious injury

or death.

▲ Do not stand between the tractor

and implement during hitching.

▲ Keep hands, feet, and clothing

away from power-driven parts.

▲ Wear snug fitting clothing to avoid

entanglement with moving parts.

▲ Watch out for wires, trees, etc.,

when raising implement. Make

sure all persons are clear of

Be Aware of

Signal Words

A Signal word designates a degree or level of hazard seriousness. The signal words are:

!DANGER

Indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury. This signal word is limited to the most extreme situations, typically for machine components that, for functional purposes, cannot be guarded.

!WARNING

Indicates a potentially hazardous situation which, if not avoided, could result in death or serious injury, and includes hazards that are exposed when guards are removed. It may also be used to alert against unsafe practices.

!CAUTION

Indicates a potentially hazardous situation which, if not avoided, may result in minor or moderate injury. It may also be used to alert against unsafe practices.

working area.

▲ Turning tractor too tight may

cause implement to ride up on

wheels. This could result in injury

or equipment damage.

For Your Protection

▲Thoroughly read and understand the “Safety Label” section, read all instructions noted on them.

Shutdown and Storage

▲Lower machine to ground, put tractor in park, turn off engine, and remove the key.

▲Detach and store implements in a area where children normally do not play. Secure implement by using blocks and supports.

OFF

8/21/06

PS25120 Primary Seeder 313-156M 1

Page 2 Page 4
Image 3
Page 2 Page 4
Contents Primary Seeder Table of Contents Safety at All Times Transport Machinery Safely Use Safety Lights and DevicesUse a Safety Chain Practice Safe MaintenanceKeep Riders Off Machinery Prepare for EmergenciesWear Protective Equipment Avoid High Pressure Fluids Hazard818-230C 818-003C818-340C 818-229C818-337C 818-339C818-338C Using This Manual ApplicationOwner Assistance Sling Brackets Pre-Assembly ChecklistSling Bracket Installation Parking Stand InstallationPull-Type Primary Seeder Acremeter InstallationTongue & Turnbuckle Assembly Spring Hose Loop AssemblyEnd Wheel Hydraulic Schematic Wheel Bracket & Wheel Arm AssemblyAccumulator Assembly Accumulator Hydraulic SchematicPull-Type Primary Seeder with Front Wheels Front Wheel Hydraulic Schematic Cylinder, Wheel Bracket & Wheel Arm AssemblyTractor 3-Point Hook-Up General DescriptionOperating Check List Tractor RequirementsTractor Drawbar Hook-Up Pull-Type and End Wheel UnitsFront Wheel Units Transporting Tractor Hydraulic Hook-UpBleeding Hydraulic System Operating Hydraulic Lift SystemParking Point SeedersPull-Type, Front or End Wheel Seeders General Operating Instructions Seed Level IndicatorSeed Level Indicator Agitator Attachment OptionalSeed Rate Speed Change Drive SystemRoller Packing Wheels Seed Broadcasting SystemLow Range High Range Turf Drive Low RangeHigh Range Ag DriveSeed Rate Adjustment Calibrating & Adjusting Seeding RateSeed Rate Charts for Ag Drive Fescue Fine Blade, Turf Type Pounds per AcreFescue Fine Blade, Turf Type Pounds per 1000 Square Feet Rye Grass Perennial Pounds per Acre Kentucky Blue Grass Pounds per AcreLovegrass Sand Pounds per Acre Rye Grass Annual Pounds per AcreBrome Grass Seed Rate Chart Wheatgrass Crested Pounds per AcreWheatgrass Western Pounds per Acre Fescue Fine Blade, Turf Type Kilograms per Hectare Metric Seed Rate Charts for Ag DriveClover Red Clover WhiteFescue K-31 Metric Brome Seed Rate Chart Bent Grass Pounds per Acre Seed Rate Charts for Turf Drive28 PS25120 Primary Seeder 313-156M Metric Seed Rate Charts for Turf Drive Clover White Kilograms per 1000 Square Meters Fescue K-31Kilograms per HectarePerennial Kilograms per Hectare Rye GrassSeed Rate Speed Change Calibrating & Adjusting Seeding RateSmall Grass Seeds Seed Rate Adjustment Small Grass Seeds Attachment OptionalBird’s-foot Trefoil Pounds per Acre Small Grass Seeds Attachment Seed RatesRed Top Kilograms per Hectare Lespedeza Unhulled Kilograms per 1000 Square MetersMillet Kilograms per Hectare Millet Pounds per 1000 Square FeetSmall Grass Seeds Attachment Metric Seed Rates Millet Kilograms per 1000 Square Meters Fescue K-31Kilograms per 1000 Square MetersDanish Tines Optional Calibrating and Adjusting Seed RateHeight Adjustment Coil Tines OptionalAdjustment w/ Small Grass Seeds Attach Adjustment w/o Small Grass Seeds AttachWalkboard Optional Required MaintenanceStorage LubricationSeasonally HoursDrive Sprocket Hanger Bearing Small Grass Seeds Attachment Feeder Cup Drive Sprocket Small Grass Seeds AttachmentAgitator Lockout Agitator Attachment Small Seeds Attachment 313-113A Agitator Attachment 313-079ACoil Tine Track Removers 313-078A Walkboard 313-130A Danish Tine Track Removers 313-077ABushel Seeders PS25 Series Primary SeederBushel and 30 Bushel Seeders Pull-Type with Front Wheels Bushel and 30 Bushel Seeders Pull-Type with End WheelsFeatures & Benefits Feed cup sprocket locked up or twisted Problem SolutionAcremeter doesn’t measure accurately Raising and lowering seeder is rough or5L x 15 8-Ply Rib Implement Torque Values ChartTire Inflation Chart Tire Size InflationWarranty Corporate Office P.O. Box Salina, Kansas 67402-5060 USA
Top Page Image Contents