Invacare SP manual Removing the Batteries from Wheelchair, Installing Batteries into Wheelchair

Page 59

SECTION 10—BATTERIES

Removing the Batteries from Wheelchair

NOTE: For this procedure, refer to FIGURE 10.3 on page 59.

1.Slide battery tray with batteries out.

2.Disconnect the battery straps.

3.Unplug front battery from rear battery.

4.Remove the front battery.

5.Slide the rear battery forward and remove it from the tray.

	FRONT OF	NOTE: 22NF Batteries
	FRONT OF	shown.
	WHEELCHAIR	shown.
		Rear Battery
		Disconnect Front Battery
		from Rear Battery Here
		Front Battery
NOTE: Battery tray		Battery Straps
shown removed for
clarity.	Battery Tray

FIGURE 10.3 Removing the Batteries from Wheelchair

Installing Batteries into Wheelchair

NOTE: For this procedure, refer to FIGURE 10.3 and FIGURE 10.4 on page 60.

NOTE: Positioning of the batteries into the battery tray is completed with battery tray positioned in wheelchair and partially pulled out. Refer to FIGURE 10.3 for full view of wheelchair base. Illustrations in FIGURE 10.4 on page 60 are shown without the wheelchair for clarification purposes only.

1.Position the battery with battery connector bracket in the rear of the battery tray in the orientation as shown. See Detail “A” of FIGURE 10.4 on page 60.

NOTE: Front of battery tray is designated by the battery stop. Rear of the battery tray is the opposite end.

NOTE: Orientation of the battery is critical otherwise batteries will not connect to the controller or each other.

2.Position the remaining battery in the front of the battery tray in the orientation shown so that the wiring harnesses can be connected together. See Detail “B” of FIGURE 10.4 on page 60.

3.Connect front battery to rear battery. See Detail “B” of FIGURE 10.4 on page 60.

4.Connect battery straps. See Detail “C” of FIGURE 10.4 on page 60.

Part No 1143190

59

TDX™ SP

Image 59

Contents TDX SP Manual Reference DocumentsReference Documents Table of Contents Safety INSPECTION/TROUBLESHOOTING Motor Locks Complete and mail the form on the next Register Your ProductCity State/Province Product Registration FormFold here Cut Along Line Meaning Special NotesSpecial Notes Trro and Trbkts Warnings Label Locations Label LocationsAll Wheelchairs Wheelchairs with 22NF BatteriesWheelchairs with GP24 Batteries Wheelchairs with Trro Wheelchairs without Trro Typical Product Parameters Typical Product ParametersGeneral Guidelines Repair or Service InformationGeneral Guidelines Operation Information Wheelchairs with Trro or Trbkts Only Tire PressureCharging Batteries ElectricalBatteries Grounding InstructionsRain Test Weight TrainingWeight Limitation EMI Information EMI InformationEMI Information Stability and Balance SAFETY/HANDLING of WheelchairsSAFETY/HANDLING of Wheelchairs Coping with Everyday Obstacles Coping with Everyday ObstaclesReaching, Leaning and Bending Reaching, Leaning and Bending ForwardPinch Points Reaching, Bending BackwardStairways Transferring To and From Other Seats Transferring To and From Other SeatsSafety INSPECTION/TROUBLESHOOTING Safety INSPECTION/ TroubleshootingSafety Inspection Checklists Inspect/Adjust InitiallyInspect/Adjust Monthly Inspect/Adjust WeeklyInspect/Adjust Every 2 Years Troubleshooting MechanicalInspect/Adjust Periodically Inspect/Adjust Every 18 MonthsDisplay Description Definition Troubleshooting ElectricalInformation Gauge Display Diagnostics SPJ+, SPJ+ w/PSS or SPJ+ w/ACC JoysticksMPJ+, PSR+, PSF+ Joysticks or Displays Service Indicator Light DiagnosticsPossible Solution Symptom Probable Cause SolutionsBAD Joystick CAL Values DON’T Checking Battery Charge LevelOperating the Wheelchair Turning the Power On/OffUsing the Joystick to Drive the Wheelchair Wheelchair OperationWheelchair Movement ActionSpeedometer On/Off ButtonCharger/Programming Input Service IndicatorSpeed Control Buttons JoystickInformation Gauge Display MPJ+ Joystick Switches and IndicatorsDrive Select Toggle Switch Selecting the Drive ModeLCD Display Screens Speed ControlMain Screen Splash ScreenWheelchair Operation Description Status IndicatorConnected Devices Screen Programmable Mono Port 1/2 or External Mode SwitchRemote Stop Switch Remote Mode Reset SwitchMemory Card Slot Remote On/Off SwitchMode Switch Van Seats Repositioning JoystickConnecting Disconnecting/Connecting the JoysticksAdjustable Asba Seats DisconnectingMPJ+ Joysticks 11 Disconnecting/Connecting Joysticks SPJ+ JoysticksMotor Locks Motor LocksDisengaging/Engaging Motor Lock Levers Disengaging Wheel LocksDisengaging/Engaging the Wheel locks EngagingPinch point may occur when rotating the footboard assembly Footboard AssemblyRemoving/Installing the Footboard InstallingRemoving/Installing the Footboard Adjusting the Footboard AngleForks Adjusting ForksForks Batteries BatteriesFor TDX SP Wheelchairs Using 22NF Batteries Using the Proper BatteriesReplacing Batteries Wire CutterReplacing Batteries Removing/Installing the Batteries From/Into the Wheelchair Cleaning Battery TerminalsBattery Retention Bracket Removing the Batteries from Wheelchair Installing Batteries into WheelchairInstalling Batteries into Wheelchair MPJ+ Joystick When to Charge BatteriesSPJ+, SPJ+ w/PSS and SPJ+ w/ACC Joysticks Charging Batteries Description and Use of Battery ChargersTool Quantity Required ItemsTransport Ready Package Trro Transport Ready Package TrroCompliance Information About Transport Ready PackagesPositioning the Wheelchair in the Vehicle SpecificationsMotor Wheelchair Weight Limit Adult Securing the Wheelchair to the VehicleSecuring the Wheelchair Securement PointsWheelchair-Anchored Belts Securing the OccupantWheelchair-Anchored Belts Seating System Vehicle-Anchored BeltsPositioning Belts Positioning BeltsUSA Limited Warranty