SECTION 10—BATTERIES
Charging Batteries
WARNING
NEVER attempt to recharge the batteries by attaching cables directly to the battery terminals or clamps. ALWAYS use the recharging plug located on the back of the joystick.
DO NOT attempt to recharge the batteries and operate the power wheelchair at the same time.
During use and charging, unsealed batteries will vent hydrogen gas which is explosive in the right concentration with air.
CAUTION
Always charge new batteries before initial use or battery life will be reduced.
NOTE: For this procedure, refer to FIGURE 10.7 on page 63.
NOTE: New batteries MUST be fully charged prior to initial use of the wheelchair.
NOTE: As a general rule, batteries should be recharged daily to assure the longest possible life and minimize the required charging time. Plan to recharge the batteries when it is anticipated the wheelchair will not be used for a long period of time.
The range per battery charge using recommended batteries should be approximately 5 to 9 hours of typical operation. Extensive use on inclines may substantially reduce per charge mileage.
Description and Use of Battery Chargers
The charger automatically reduces the charge from an initially high rate to a zero reading at a fully charged condition. If left unattended, the charger should automatically shut‐off when full charge is obtained.
There are some basic concepts which will help you understand this automatic process. They are:
The amount of electrical current drawn within a given time to charge a battery is called the “charge rate”. If, due to usage, the charge stored in the battery is low, the charge rate is high, as indicated by the GREEN light on the charger. Initially, the GREEN light will stay illuminated for a short period of time followed by a longer period of off time. As a charge builds up, the charge rate is reduced, and the GREEN light will stay illuminated for a longer period of time followed by a shorter off time.
WARNING
NEVER leave the charger unattended when the breaker has tripped. A fault condi- tion exists. Unplug and discontinue using immediately. Contact an Invacare dealer.
NOTE: If performing the charging procedures independently, READ and CAREFULLY follow the individual instructions for each charger (supplied or purchased).
TDX™ SP | 62 | Part No 1143190 |