14
FINAL ASSEMBLY
ATTACHING THE HANDLE
Attach the handle as shown so that when the door is closed, the handle will be centred in the slot located on the
fireplace front. To achieve this you may have to experiment (on the upper and lower screws) with one of the variations shown. Tighten securely.
TOP FLAME SPREADER
BOTTOM FLAME SPREADER
FIBRE BAFFLE (1 OF 2 SHOWN)
TOP FIREBRICK (1 OF 2 SHOWN)
FIGURE 23
FIGURE 24
FIGURE 25
TOP FIREBRICK AND BAFFLE
INSTALLATION
The fi replace is shipped with the fi rebricks in place. Top fi rebricks, fi bre baffl es and gasket rope are not installed.
FIBRE BAFFLE
|
| TOP FIREBRICK |
| |||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| TUBE | |||
|
|
|
|
| TUBE | |
|
|
|
|
| RETAINER | |
1 |
|
|
|
| FIGURE 26 | |
|
|
|
|
|
|
|
1Unscrew and remove the front tube retainer. Note that the first tube retainer also holds the side brick in place. Slide the tube
either to the left or right and remove. Remove the two middle tubes in the same fashion.
1
3a |
| FIGURE 28 |
|
|
!WARNING
Operation of the fi replace without the top fi rebricks and the baffles can result in excessive temperatures that could dam- age the fi replace, chimney and the surrounding enclosure.
BAFFLE SUPPORT BRACKET
3b
FIGURE 29
3Insert the left baffl e, then the left top fi rebrick. Repeat using the right baffl e and brick.
The baffl es are made of a brittle material. Care must be taken not to bend or force them.
Replace the three front tubes. Position the center edg- es of both baffles and bricks until they lie snugly together. Slide the baffl e support bracket into place along the front of the unit between the front tube and the two top fi rebricks.
REAR
BRICKS
GASKET ROPE LOCATION
|
| FIGURE 27 |
2 |
| |
|
|
2Place gasket rope along the upper ledge of the air chamber and on the top of the rear bricks. The top and bottom fl ame
spreaders come taped together. This tape will burn away in the initial
firing of the unit. On subsequent brick removals, the bottom fl ame spreader must be taped to the top spreader to ease top brick and baffl e removal and to avoid damaging the fi bre baffl es.
4 |
| FIGURE 30 |
|
|
|
NorthlineExpress.com | http://www.northlineexpress.com |