Supra SUPRA, THE LOGO manual Transmission Level Check, Drive Fluid Check, Change Frequency

Page 64

Transmission Level Check

Use only automatic transmission fluid type “A” in transmissions with 1:1 drive train. Refer to Engine Owner’s Manual.

Change Frequency

Change transmission fluid every year, using only Dextron-III Mercon automatic transmission fluid.

Maintaining Fluid Level

Transmission fluid level should be checked regularly and fluid added if necessary. Maintain fluid levels as follows:

-Boat must be at rest.

-Engine should be at operating temperature, but turned off while checking level.

-Remove transmission dipstick.

-Wipe fluid clean from dipstick and replace.

-Remove dipstick and note level indicated by the upper and lower marks.

-If required, add fluid to bring the level to the upper mark.

V-Drive Fluid Check

The fluid level can be checked by using the oil level gauge, which is located on top of the V-Drive unit. This unit is located under the center cushion of the rear seat. Pull out the cushion to access the transmission.

Pull the oil level gauge to check the fluid level. If the level is low, add fluid to the correct mark on the dipstick. Use SAE 30 motor oil.

NOTE: Only a trained and qualified technician should perform the oil change on your V-drive unit.

Change Frequency

The oil should be changed in the V-drive unit after the first 100 hours of operation, then each year at the end of your boating season.

Maintaining Fluid Level

V-Drive unit fluid level should be checked regularly and fluid added if necessary. Maintain fluid levels as follows:

-Boat must be at rest.

-Engine should be at operating temperature, but turned off while checking level.

-Remove fluid dipstick.

-Wipe fluid clean from dipstick and replace.

-Remove dipstick and note level indicated by the upper and lower marks.

-If required, add fluid to bring the level to the upper mark.

— 64	© 2006 Skier’s Choice, Inc.

Image 64

Contents Trademarks Table of Contents Boat InformationIntroduction IntroductionCheck Before running where applicable Important Safety Information Boating SafetySafety Training Organizations Safety EquipmentGeneral Safety Precautions Boaters must continuously be aware of weather conditionsSkiing Safety Carbon Monoxide CO SafetySki Pylon Extensions Product MisuseProper Seating Contact InformationSkier’s Choice, Inc Emergency Procedures Device when boatingGrounding People or damage the boatVisual Distress Signals Audible Distress Signals Basic Boating Rules Boating RulesEncountering Other Vessels Review and understand all local and state lawsSee examples of buoys and markers next Skier’s Choice, Inc Skier’s Choice, Inc Boat Specifications Comp SunsportSunsport Launch Launch 20SSV Launch Launch 22SSV Launch 24SSV Skier’s Choice, Inc Operating Information Break In PeriodStarting & Operation Maximum Capacities Coast Guard RegulationsDo not exceed the maximum capacity of the boat Starting & Operation To Start Electronic Fuel Injection EFI EngineThrottle Lever Engine Warm-UpTransmission Lockout Bilge Area Center Drain Plug Rear Drain PlugFuel Precautions Filling the TankFueling Before FuelingInstrument Panel & Controls Speed CalibrationTemperature Gauge SpeedometerTachometer Engine HoursFuel Gauge Speedometer Paddle WheelVoltmeter Oil Pressure GaugeSetting Units Setting Deep AlarmSetting Shallow Alarm Depth SounderTroubleshooting Instrument does not Turn on TroubleshootingOut of Range Display Adjusting The Boat Speed Stereo EZ CruiseActivating The Cruise System Disengaging The SystemSkier’s Choice, Inc Skier’s Choice, Inc Ignition Switch Blower Switch Horn SwitchSupra dealer Boat is in storageSafety Lanyard/Engine Shut Off Switch Tilt SteeringDrive Warning Light Circuit Breaker PanelDC Outlet Gravity Ballast SystemPriming the System Skier’s Choice, Inc Ignition Keys Equipment & OptionsMirrors Driver’s Seat & Seat Adjustment Inboard Motor BoxDrive Engine Compartment Never open the Motor Box while the boat is movingFlame Precautions Fire ExtinguisherDrive Ski Pylon Inboard Ski PylonRad-A-Cage Pole Light Receptacle Pole LightTower Navigation Light Courtesy LightsLifting Rings Ski PlatformBow Eye See Hoisting InstructionsDetachable Bracket Ski LockerBilge Inspection Plate 20 & 24 V-Drive Sundeck StepwaySundeck PropellerDouble-Up Seating Triple-Up SeatingTrim Switch & Gauge Hydraulic Wake PlateOptional Perfect Pass Glove BoxOptional Boat Heater Optional Bimini Tops Walk-Thru WindshieldBattery Box Dual Battery Option HookupCooler Wakeboard RacksOptional Tower Speakers Transom Mount Stereo RemoteOptional Tonneau Cover Mooring CoverOptional Cockpit Cover Optional Subwoofer Optional Satellite Radio Air Inflator Optional Stereo AmpDo not leave air inflator running unattended Optional Water Strainer Optional Walk-Through CurtainFuel Tank Drive Fuel TankFuel Vent While FuelingAutomatic Fire Suppression System Docking LightsJump Seat Skier’s Choice, Inc Service & Maintenance Service & MaintenanceComponent Lubrication Cooling SystemsFuel Filter Engine Oil and Filter Drive Remote Oil FilterOil Level Check Refer to Engine Manual for more informationTransmission Level Check Drive Fluid CheckChange Frequency Maintaining Fluid LevelInstallation & Precautions Shaft Log Packing NutSkier’s Choice, Inc Cleaning, Care & Storage Fiberglass CareWashing Your Boat Rub Rail CareUpholstery Care Drying UpholsteryForeign Deposits Boat Hull ProtectionWinterization & Dry Storage WinterizationSummerization Temporary Hoisting Do not use the ski pylon to hoist the boatIdentification Number Technical InformationSkier’s Choice, Inc Trailering Your Boat Trailer Plug Wire SchematicTrailer & Towing Prolong Trailer Life Connecting the TrailerTrailer Alignment Unloading Procedure Loading ProcedureBoat Buddy Surge Brakes Fluid ReservoirGold Series Oil Bath Bearings LoadingTandem Axle Second Axle Disc BrakesAluminum Step Plate Swing-Away TongueLaser Cut Steps LED PackageAluminum Wheels Supra Limited Warranty Supra WarrantyOther Limitations Owner’s Responsibility Dealer’s ResponsibilitySkier’s Choice, Inc Index Index Skier’s Choice, Inc Skier’s Choice, Inc Skier’s Choice, Inc Skier’s Choice, Inc