Multiquip manual MT-84F Safety Message Alert Symbols

Page 6

MT-84F — SAFETY MESSAGE ALERT SYMBOLS

FORYOUR SAFETY AND THE SAFETY OF OTHERS!

HAZARD SYMBOLS

Safety precautions should be followed at all times when operating this equipment. Failure to read and understand the Safety Messages and Operating Instructions could result in injury to yourself and others.

This Owner's Manual has been developed to provide complete instructions for the safe and efficient

NOTE operation of the MQ Mikasa, Model MT-84F Tamping Rammer. Refer to the engine manufacturers instructions for data relative to its safe operation.

Before using this rammer, ensure that the operating individual has read and understands all instructions in this manual.

SAFETY MESSAGE ALERT SYMBOLS

The three (3) Safety Messages shown below will inform you about potential hazards that could injure you or others. The Safety Messages specifically address the level of exposure to the operator, and are preceded by one of three words: DANGER,

DANGER

You WILL be KILLED or SERIOUSLY INJURED

if you DO NOT follow these directions.

WARNING

You CAN be KILLED or SERIOUSLY INJURED if

you DO NOT follow these directions.

CAUTION

You CAN be INJURED if you DO NOT follow these directions.

Potential hazards associated with the operation of a MT-84F Tamping Rammer will be referenced with Hazard Symbols which appear throughout this manual, and will be referenced in conjunction with Safety Message Alert Symbols.

WARNING Lethal Exhaust Gas Hazards

Engine exhaust gases contain poisonous carbon monoxide. This gas is colorless and odorless, and can cause death if inhaled. NEVER operate this equipment in a confined area or enclosed structure that does not provide ample free flow air.

WARNING Explosive Fuel Hazards

Gasoline is extremely flammable, and its vapors can cause an explosion if ignited. DO NOT start the engine near spilled fuel or combustible fluids.

DO NOT fill the fuel tank while the engine is running or hot. DO NOT overfill tank, since spilled fuel could ignite if it comes into contact with hot engine parts or sparks from the ignition system. Store fuel in approved containers, in well-ventilated areas and away from sparks and flames.

 

WARNING

Burn Hazards

Engine components can generate extreme heat. To prevent burns, DO NOT touch these areas while the engine is running or immediately after operations. Never operate the engine with heat shields or heat guards removed.

 

WARNING

Respiratory Hazards

ALWAYS wear approved respiratory protection when required.

PAGE 6 — MT-84F — OPERATION & PARTS MANUAL — REV. #2 (06/30/05)

Page 5 Page 7
Image 6
Page 5 Page 7
Contents Model MT-84F MT-84F Proposition 65 Warning MT-84F Operation & Parts Manual REV. #2 06/30/05 MT-84F Table of Contents MT-84F Parts Ordering Procedures When ordering parts Please supply the following informationMT-84F Safety Message Alert Symbols MT-84F Safety Message Alert Symbols Rotating Parts HazardsMT-84F Rules for Safe Operation MT-84F Rules for Safe Operation Machine Safety Decals Rammer Operation and Safety DecalsMT-84F Operation and Safety Decals Construction of Tamping Rammer MT-84F General InformationDefinition of Tamping Rammer Rammer Gearbox and Spring CylinderMT-84F Specifications MT-84F Controls and Components MT-84F Basic Engine Robin EH-12-2D Engine Controls and ComponentsMT-84F Operation Rammer Gearbox and Spring Cylinder Oil BathFuel Check Inspection Initial Start-upOperation Stopping The EngineMaintenance 200 300 Hours Pre-CleanerLong Term Storage MT-84F -TROUBLESHOOTING Guide MT-84F -TROUBLESHOOTING Guide QTY. Column NO. ColumnPart NO. Column Remarks ColumnMT-84F- Suggested Spare Parts MT-84F Rammer 1TO 3 UnitsMT-84F- Nameplate and Decals Part Name QTY Remarks MT-84F Crankcase and Engine Assy Part Name 28 MT-84F Operation & Parts Manual REV. #2 06/30/05 MT-84F Crankcase and Engine Assy MT-84F Guide Cylinder and Foot Assy Piston PIN MT-84F -TANK and Handle Assy Tank CAP ASSY., OR,DB Robin EH-12-2D Engine Crankcase and Cylinder Assy Robin EH-12-2D Engine Crankcase and Cylinder Assy Robin EH-12-2D Engine Crankshaft and Piston Assy Crankshaft CP Robin EH-12-2D ENGINE-MUFFLER, AIR CLEANER, CAM& CARB. Assy Robin EH-12-2D Engine -MUFFLER, AIR CLEANER, CAM& CARB. Assy Robin EH-12-2D Engine -GOVERNOR Assy Governor Lever CP Robin EH-12-2D Engine -RECOIL Starter and Blower Assy Robin EH-12-2D Engine -RECOIL Starter and Blower Assy Robin EH-12-2D Engine Magneto Assy Flywheel CP Robin EH-12-2D Engine Carburetor Assy Throttle Valve Effective October 1, 2002 Terms and Conditions of Sale Parts MT-84F Operation & Parts Manual REV. #2 06/30/05 Heres HOW to GET Help
Top Page Image Contents